 |
Used 1996 Chevrolet Corsica Recalls
Components: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSU...
Cars Affected: 742
Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequences:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
|
|
|
Used 1994 Chevrolet Corsica Recalls
Components: SUSPENSION:FRONT
Cars Affected: 39
Summary:
THE SUSPENSION SUPPORT ASSEMBLIES DO NOT MEET GENERAL MOTORS CORPORATION'S SPECIFICATION FOR WELD INTEGRITY AND THE AFFECTED WELD CAN FAIL CAUSING THE FRONT OF THE CONTROL ARM TO SEPARATE FROM THE SUSPENSION SUPPORT ASSEMBLY.
Consequences:
IF THIS OCCURS, THE AFFECTED TIRE/WHEEL ASSEMBLY CAN MOVESUBSTANTIALLY FROM ITS DESIGNED POSITION AND STEERING CONTROL CAN BE SEVERELYIMPAIRED WHICH MAY RESULT IN AN ACCIDENT.
Remedy:
INSTALL REVISED SUSPENSION SUPPORTS WITH ADEQUATE WELD INTEGRITY.
|
|
|
Used 1992 Chevrolet Corsica Recalls
Components: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Cars Affected: 140,661
Summary:
THE SERVICE BRAKE STOP LAMP SWITCH BECOMES INOPERATIVE.
Consequences:
THE INOPERATIVE STOP LAMP SWITCH WILL NOT ILLUMINATE THESTOP LAMPS WHEN THE BRAKE PEDAL IS DEPRESSED. THIS WOULD NOT ADEQUATELY INFORMOTHER DRIVERS OF THE VEHICLE OPERATOR'S INTENT TO STOP OR SLOW DOWN.
Remedy:
REPLACE THE STOP LAMP SWITCH AND CORRECT THE WIRING IN THE CONNECTOR OF THE STOP LAMP SWITCH WIRING HARNESS.
|
|
|
Used 1991 Chevrolet Corsica Recalls
Components: STEERING:WHEEL AND HANDLE BAR
Cars Affected: 36,364
Summary:
NUT ATTACHING STEERING WHEEL MAY NOT HAVE BEEN PROPERLY TIGHTENED DURING INSTALLATION.
Consequences:
THIS COULD ALLOW STEERING WHEEL TO SEPARATE FROM STEERINGCOLUMN; LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy:
TIGHTEN THE NUT TO THE PROPER TORQUE AS NECESSARY.
|
|
|
Used 1990 Chevrolet Corsica Recalls
Components: SEAT BELTS
Cars Affected: 722,884
Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequences:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Remedy:
Components: SEAT BELTS:REAR
Cars Affected: 26,464
Summary:
OWNER'S MANUALS WERE PRINTED WITH REAR CENTER SEAT BELT INFORMATION OMITTED.
Consequences:
THIS WOULD NOT COMPLY WITH FMVSS 209.
Remedy:
INSERT MISSING INFORMATION INTO OWNERS MANUAL.
|
|
|
Used 1989 Chevrolet Corsica Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: WHEELS
Cars Affected: 19,603
Summary:
THE STYLED STEEL WHEELS CAN HAVE CRACKS DEVELOPING AT THE OUTER EDGES OF THE WHEEL WHERE THE SPOKES MEET THE RIM. THE CRACKS PROPAGATE FROM EACH SIDE OF A SPOKE TOWARD EACH OTHER, AND EVENTUALLY MEET. THE MEETING OF THE CRACKS RESULTS IN COMPLETE SEAPARATION OF A SPOKE FROM THE WHEEL.
Consequences:
THE CRACKING CONDITION CAN OCCUR ON EVERY SPOKE ON THEWHEEL, CAUSING COMPLETE SEPARATION OF THE WHEEL FROM THE VEHICLE, AND RESULTINGIN LOSS OF STEERING AND BRAKING CONTROL.
Remedy:
REPLACE THE INVOLVED WHEEL ASSEMBLIES.
Components: SEAT BELTS
Cars Affected: 722,884
Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequences:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Remedy:
Components: SEATS
Cars Affected: 642
Summary:
THE FRONT SEAT FRAME ASSEMBLY MAY CONTAIN AN IMPROPER, MISSING AND/OR MISLOCATED WELD THAT COULD FRACTURE.
Consequences:
THIS COULD CAUSE UNEXPECTED SEAT MOVEMENT AND RESULT INPERSONAL INJURY AND/OR LOSS OF CONTROL OF THE CAR.
Remedy:
REPLACE BOTH FRONT SEAT ASSEMBLIES.
Components: SEAT BELTS
Cars Affected: 29,951
Summary:
FRONT SEAT BELT LATCH PLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES.
Consequences:
IN EVENT OF AN ACCIDENT, UNBELTED OR IMPROPERLY BELTEDOCCUPANTS ARE MORE AT RISK TO INJURY THAN IF BELTS ARE PROPERLY BUCKLED.
Remedy:
REPLACE IMPROPERLY FUNCTIONING BUCKLE ASSEMBLIES.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Cars Affected: 13,095
Summary:
A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.
Consequences:
IN PRESENCE OF AN IGNITION SOURCE, THIS CONDITION COULDRESULT IN A FIRE.
Remedy:
REPLACE FUEL TANK.
|
|
|
Used 1988 Chevrolet Corsica Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: SEAT BELTS
Cars Affected: 722,884
Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequences:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Remedy:
Components: STRUCTURE:BODY:HOOD
Cars Affected: 290,408
Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequences:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Remedy:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 170,769
Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequences:
HINGE SEPERATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Remedy:
REPLACE DOOR HINGES ON BOTH DOORS.
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 282,052
Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequences:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
|
|
|
Used 1987 Chevrolet Corsica Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: STRUCTURE:BODY:HOOD
Cars Affected: 290,408
Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequences:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Remedy:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 170,769
Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequences:
HINGE SEPERATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Remedy:
REPLACE DOOR HINGES ON BOTH DOORS.
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 282,052
Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequences:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 2,020
Summary:
LOSS OF SKID PLATE COULD LEAD TO DISENGAGEMENT OF BOTH SECONDARY AND PRIMARY HOOD LATCHES.
Consequences:
HOOD COULD OPEN UNEXPECTANTLY; IF VEHICLE WERE INMOTION, THE HOOD COULD CONTACT THE WINDSHIELD, REDUCE THE DRIVERS VISION AREA,AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy:
INSTALL A SECONDARY LATCH SKID PLATE AND/OR SECONDARY LATCH SKID PLATE RETAINING SCREWS.
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 4,844
Summary:
SECONDARY HOOD LATCH MAY NOT PROPERLY ENGAGE DUE TO CONTACT WITH SUPPORT BRACKET AND/OR THE PRIMARY LATCH RETURN SPRING. CONSEQUENCE OF DEFECT: IF THIS OCCURS WHILE VEHICLE IS IN MOTION, HOOD COULD OPEN AND CONTACT THE WINDSHIELD, AFFECTING THE DRIVERS VISION AREA; THIS COULD RESULT IN A CRASH WITHOUT WARNING.
Consequences:
Remedy:
INSTALL SECONDARY LATCH SKID PLATE ON CORSICA AND BERETTA MODELS. ALSO, INSTALL A REVISED SECONDARY LATCH ASSEMBLY ON BERETTA MODELS.
Components: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Cars Affected: 1,958
Summary:
PART OF PUSHBUTTON ATTACHMENT OF HEADLIGHT SWITCH MAY FRACTURE. CONSEQUENCE OF DEFECT: PUSH BUTTON WOULD NOT LATCH IN ON POSITION RESULTING IN INABILITY TO TURN ON HEADLIGHTS, REDUCED DRIVER VISIBILITY, AND THE POTENTIAL FOR A CRASH.
Consequences:
Remedy:
INSTALL NEW HEADLIGHT SWITCH.
|
|
|
