 |
Used 1992 Chrysler Lebaron Recalls
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 17,000
Summary:
THE HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY INSTALLED AND THE SECONDARY HOOD LATCH MAY BE PREVENTED FROM ENGAGING WHEN THE HOOD IS CLOSED.
Consequences:
IF THE PRIMARY HOOD LATCH ENGAGEMENT FAILS, THE LACK OFENGAGEMENT BY THE SECONDARY HOOD LATCH COULD CAUSE THE HOOD TO OPEN WHILE THEVEHICLE IS IN MOTION, REDUCING OPERATOR'S ABILITY TO SEE THE ROAD AND ONCOMINGTRAFFIC, AND POSSIBLY RESULTING IN A VEHICLE ACCIDENT.
Remedy:
ADJUST THE SECONDARY HOOD LATCH TO ALLOW THE LATCH ASSEMBLY TO PROPERLY ENGAGE WHEN THE HOOD IS CLOSED.
Components: STEERING:WHEEL AND HANDLE BAR
Cars Affected: 20,000
Summary:
THE ZINC PLATING OPERATION PERFORMED ON THE UPPER STEERING COLUMN SHAFT COUPLING BOLT CAUSED HYDROGEN EMBRITTLEMENT AND BREAKAGE OF THE BOLT.
Consequences:
FRACTURES OF THE UPPER STEERING COLUMN SHAFT COUPLINGBOLT RESULT IN A LACK OF COUPLING LOAD ON THE SHAFT AND LOSS OF STEERINGCONTROL.
Remedy:
REPLACE THE ZINC PLATED BOLT WITH A PHOSPHATE PLATED BOLT.
|
|
|
Used 1991 Chrysler Lebaron Recalls
Components: STRUCTURE:BODY:DOOR
Cars Affected: 57,000
Summary:
THE OWNER'S MANUAL INCORRECTLY STATES THAT THE FRONT PASSENGER DOOR CANNOT BE OPENED FROM THE INSIDE IF THE DOOR IS LOCKED UNTIL THE LOCK CONTROL HANDLE HAS BEEN PULLED UP. ON THESE VEHICLES, THE FRONT PASSENGER DOOR CAN BE OPENED BY THE INSIDE DOOR HANDLE EVEN IF THE DOOR IS LOCKED.
Consequences:
THE ERROR IN THE OWNER'S MANUAL MAY LEAD A FRONT SEATPASSENGER TO MISTAKENLY OPEN THE CAR DOOR WHILE THE VEHICLE IS IN MOTION,BELIEVING THE INSIDE DOOR HANDLE WOULD NOT OPEN IF THE DOOR WAS LOCKED. THISCOULD RESULT IN AN INJURY TO THE FRONT SEAT PASSENGER.
Remedy:
NOTIFY THE VEHICLE OWNERS OF THE ERROR IN THE OWNER'S MANUAL AND INFORM THEM OF THE ACTUAL OPERATION OF THE FRONT DOOR LOCK SYSTEM.
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 130,000
Summary:
FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.
Consequences:
LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.
Remedy:
REPLACE BUCKLE LATCH ENGAGEMENT.
Components: PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE A...
Cars Affected: 90
Summary:
MISMATCHED PARKING BRAKE CABLE LENGTHS TO THE REAR WHEELS REDUCES BRAKING ABILITY OF ONE OF THE REAR WHEELS, IN VIOLATION OF FMVSS 105.
Consequences:
INSUFFICIENT BRAKING ABLITY COULD RESULT IN INADVERTENTVEHICLE ROLLAWAY WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Remedy:
REPLACE MISMATCHED PARKING BRAKE CABLE WITH ONE OF CORRECT LENGTH.
Components: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Cars Affected: 398
Summary:
THE TWO AIR BAG SYSTEM FRONT IMPACT SENSORS MAY NOT BE SECURED TO THEIR MOUNTING BRACKETS.
Consequences:
AIR BAG WILL NOT DEPLOY IN A FRONTAL COLLISION IF THEFRONT IMPACT SENSORS ARE NOT ATTACHED.
Remedy:
REPAIR TO ASSURE PROPER ATTACHMENT OF FRONT IMPACT SENSORS TO BRACKETS.
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 18,000
Summary:
FRONT DISC BRAKE CALIPER GUIDE PIN BOLTS MAY NOT HAVE BEEN ADEQUATELY TORQUED AND COULD LOOSEN.
Consequences:
THIS COULD CAUSE REDUCED BRAKING EFFECTIVENESS AND COULDRESULT IN AN ACCIDENT.
Remedy:
PROPERLY TORQUE FRONT BRAKE CALIPER GUIDE PIN BOLTS TO 250 POUNDS.
|
|
|
Used 1990 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Cars Affected: 257
Summary:
AIR BAG INFLATOR MODULES MAY NOT CONTAIN DIFFUSER HOLES BETWEEN THE IGNITOR AND PROPELLANT CHAMBERS.
Consequences:
AIR BAGS WOULD NOT DEPLOY IN AN IMPACT SITUATION, WHICH COULD LEAD TO DRIVER INJURY.
Remedy:
REPLACE AIR BAG INFLATOR MODULES WITH PROPERLY MACHINED MODULES.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 634,000
Summary:
THE ENGINE VALVE COVER GASKET MAY DISLOCATE AND ALLOW AN ENGINE OIL LEAK AT THE GASKET.
Consequences:
THE LEAKAGE OF OIL IN THE ENGINE COMPARTMENT COULD CAUSEA FIRE.
Remedy:
REPLACE GASKET COVER WITH REVISED COVER, AND RTV SEALANT WILL BE APPLIED IN PLACE OF A GASKET.
|
|
|
Used 1989 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 41,000
Summary:
THE BONDED DISC BRAKE LININGS MAY SEPARATE FROM THE SHOES DUE TO A BONDING DEFICIENCY WHICH MAY ALLOW CORROSION DEGRADATION OF THE BOND ATTACHMENT.
Consequences:
SEPARATION OF THE DISC BRAKE LININGS RESULTS IN ANINCREASE IN STOPPING DISTANCE.
Remedy:
REPLACE THE FRONT AND REAR LININGS ON VEHICLES WITH 15 INCH BRAKES. REPLACE ONLY THE REAR BRAKE LININGS ON VEHICLES WITH 14 INCH BRAKES BECAUSE THE FRONT LININGS ON THESE VEHICLES ARE RIVETED.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 634,000
Summary:
THE ENGINE VALVE COVER GASKET MAY DISLOCATE AND ALLOW AN ENGINE OIL LEAK AT THE GASKET.
Consequences:
THE LEAKAGE OF OIL IN THE ENGINE COMPARTMENT COULD CAUSEA FIRE.
Remedy:
REPLACE GASKET COVER WITH REVISED COVER, AND RTV SEALANT WILL BE APPLIED IN PLACE OF A GASKET.
|
|
|
Used 1988 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
|
|
|
Used 1987 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 580,000
Summary:
FUEL LEAKAGE MAY OCCUR IN LOW AMBIENT TEMPERATURE OPERATION AT CONNECTIONS OF AN ENGINE COMPARTMENT FUEL SUPPLY HOSE TO THE PRESSURE REGULATOR AND TO THE FUEL RAIL.
Consequences:
IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE COULDRESULT IN A FIRE.
Remedy:
RELOCATE PRESSURE REGULATOR; REPLACE FUEL SUPPLY WITH FORMED HOSE WITH REVISED ROUTING CONFIGURATION TO ENSURE SEALING INTEGRITY.
Components: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Cars Affected: 4,400
Summary:
DRIVERS FLOORMAT MISPOSITIONED SUCH AS TO INTERFERE WITH ACCELERATOR PEDAL.
Consequences:
FLOORMAT MAY RESTRICT RETURN OF ACCELERATOR PEDAL TO THEIDLE POSITION.
Remedy:
FLOORMAT WILL BE REPLACED WITH A REDESIGNED MAT TO ELIMINATE THE INTERFERENCE.
|
|
|
Used 1986 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 580,000
Summary:
FUEL LEAKAGE MAY OCCUR IN LOW AMBIENT TEMPERATURE OPERATION AT CONNECTIONS OF AN ENGINE COMPARTMENT FUEL SUPPLY HOSE TO THE PRESSURE REGULATOR AND TO THE FUEL RAIL.
Consequences:
IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE COULDRESULT IN A FIRE.
Remedy:
RELOCATE PRESSURE REGULATOR; REPLACE FUEL SUPPLY WITH FORMED HOSE WITH REVISED ROUTING CONFIGURATION TO ENSURE SEALING INTEGRITY.
Components: SEATS:FRONT ASSEMBLY:POWER ADJUST
Cars Affected: 1,500
Summary:
A SERVICE REPLACEMENT DRIVERS SEAT CUSHION (MANUAL SEAT TYPE) MAY CONTAIN WRONG CUSHION WITH A BRACE THAT COULD INTERFERE WITH POWER SEAT ADJUSTER MECHANISM AND CAUSE STRESS ON THE FRAME.
Consequences:
SEAT FRAME COULD FRACTURE AND RESULT IN SIGNIFICANTREARWARD MOVEMENT OF THE SEAT BACK.
Remedy:
REPLACE FRAME WITH PROPER POWER SEAT FRAME.
Components: ELECTRICAL SYSTEM:BATTERY
Cars Affected: 32,149
Summary:
BATTERY CAP VENTS MAY BE PARTIALLY OR COMPLETELY BLOCKED WITH PLASTIC FLASHING. CONSEQUENCE OF DEFECT: A BUILD UP OF INTERNAL GAS PRESSURE COULD OCCUR WHICH COULD RESULT IN CASE RUPTURE, PARTICULARLY DURING POST CHARGING. SHOULD A PERSON BE IN THE VICINITY OF THE BATTERY WHEN THE CASE RUPTURES, THEY MAY BE INJURED BY THE RELEASED GASES AND/OR ACID.
Consequences:
Remedy:
REWORK BATTERIES BY PROBING BOTH VENT ORIFICES TO ELIMINATE ANY VENT OBSTRUCTION.
Components: ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
Cars Affected: 7,600
Summary:
A RESISTOR IN THE ELECTRONIC PANEL CLUSTER MAY BE SUBJECTED TO AN ELECTRICAL CURRENT OVERLOAD DUE TO FAILURE OF A SWITCHING TRANSISTOR. CONSEQUENCE OF DEFECT: THE OVERHEATED RESISTOR COULD IGNITE AND START AN INSTRUMENT PANEL FIRE.
Consequences:
Remedy:
MODIFY INSTRUMENT PANEL CLUSTER BY REPLACING THE RESISTOR WITH A FUSED RESISTOR THAT WILL NOT IGNITE IF OVERLOADED.
|
|
|
Used 1985 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: SEATS
Cars Affected: 60,000
Summary:
DRIVERS SEAT FRAME MAY EXPERIENCE FATIGUE FAILURE AT ONE (FRONT/OUTBOARD) OF ITS FOUR ATTACHMENTS.
Consequences:
THIS COULD RESULT IN SOME FORWARD, BACKWARD OR LATERALMOVEMENT OF SEAT, CREATING A POTENTIAL FOR LOSS OF CONTROL OF THE VEHICLEWHICH COULD RESULT IN AN ACCIDENT
Remedy:
REPLACE DRIVERS SEAT FRAME WITH A STRENGHTENED VERSION; ALSO, REINFORCE POWER ADJUSTER FRONT CROSSMEMBER TO INCREASE RIGIDITY OF SEAT ATTACHMENT SYSTEM.
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 580,000
Summary:
FUEL LEAKAGE MAY OCCUR IN LOW AMBIENT TEMPERATURE OPERATION AT CONNECTIONS OF AN ENGINE COMPARTMENT FUEL SUPPLY HOSE TO THE PRESSURE REGULATOR AND TO THE FUEL RAIL.
Consequences:
IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE COULDRESULT IN A FIRE.
Remedy:
RELOCATE PRESSURE REGULATOR; REPLACE FUEL SUPPLY WITH FORMED HOSE WITH REVISED ROUTING CONFIGURATION TO ENSURE SEALING INTEGRITY.
Components: SEATS:FRONT ASSEMBLY:POWER ADJUST
Cars Affected: 1,500
Summary:
A SERVICE REPLACEMENT DRIVERS SEAT CUSHION (MANUAL SEAT TYPE) MAY CONTAIN WRONG CUSHION WITH A BRACE THAT COULD INTERFERE WITH POWER SEAT ADJUSTER MECHANISM AND CAUSE STRESS ON THE FRAME.
Consequences:
SEAT FRAME COULD FRACTURE AND RESULT IN SIGNIFICANTREARWARD MOVEMENT OF THE SEAT BACK.
Remedy:
REPLACE FRAME WITH PROPER POWER SEAT FRAME.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 53,000
Summary:
AN ENGINE COMPARTMENT FUEL HOSE ROUTED TO THE FUEL SYSTEM PRESSURE REGULATOR MAY HAVE AN INADEQUATELY TIGHTENED HOSE CLAMP. CONSEQUENCE OF DEFECT: THE FUEL HOSE COULD LEAK AND RESULT IN AN ENGINE COMPARTMENT FIRE.
Consequences:
Remedy:
REPOSITION AND TIGHTEN TO THE PROPER TORQUE LEVEL OF THE FUEL HOSE CLAMP.
Components: SEAT BELTS:FRONT
Cars Affected: 208
Summary:
REQUIRED FRONT CENTER SEAT BELT ASSEMBLY WAS OMITTED. VEHICLES ARE NOT IN COMPLIANCE WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 209, SEAT BELT ASSEMBLIES.
Consequences:
Remedy:
INSTALLATION OF MISSING CENTER SEAT BELT WILL BE DONE WITHOUT CHARGE.
|
|
|
Used 1984 Chrysler Lebaron Recalls
Components: SUSPENSION
Cars Affected: 6,903
Summary:
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequences:
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 340,000
Summary:
THE POTENTIAL FOR FUEL LEAKAGE EXISTS IN THE ENGINE COMPARTMENT AT THE FUEL RESERVOIR SEAM AND ITS HOSE CONNECTIONS. THE FUEL RESERVOIR IS A SILVER COLORED CAN MOUNTED TO THE AIR CLEANER.
Consequences:
Remedy:
THE HOSES AND THE METAL TUBE THAT ATTACHES TO THE FUEL RESERVOIR WILL BE REPLACED WITH NEW COMPONENTS. THE DEALER WILL ALSO REPLACE OR RESEAL THE RESERVOIR.
|
|
|
Used 1983 Chrysler Lebaron Recalls
Components: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Cars Affected: 500,000
Summary:
FRONT SUSPENSION CROSSMEMBER MAY CORRODE AND FAIL AT LOWER CONTROL ARM REAR PIVOT MOUNTS IF OPERATED WHERE SALT IS USED TO AID IN SNOW REMOVAL.
Consequences:
CONTROL ARM COULD DETACH FROM THE CROSSMEMBER, ADVERSELYAFFECTING DIRECTIONAL STABILITY, WHICH COULD RESULT IN AN ACCIDENT.
Remedy:
INSTALL ATTACHMENT REINFORCEMENT BRACKETS TO PREVENT CONTROL ARM DETACHMENT AS A RESULT OF CORROSION WEAKENING.
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 50,000
Summary:
HYDRAULIC BRAKE TUBING ROUTED TO THE LEFT REAR WHEEL BRAKE SYSTEM MAY HAVE BEEN BENT OUT OF SHAPE DURING ASSEMBLY AND COULD CHAFE AGAINST THE EXHAUST SYSTEM HANGER BOLT.
Consequences:
Remedy:
DEALER WILL INSPECT AND RELOCATE TUBE, IF NECESSARY. A RETAINING CLIP WILL BE INSTALLED TO ENSURE ADEQUATE CLEARANCE FOR THE TUBING; ANY DAMAGED TUBES WILL ALSO BE REPLACED.
Components: EQUIPMENT:ELECTRICAL
Cars Affected: 479
Summary:
THE TRAVEL COMPUTER SYSTEM WIRING, ON THE INVOLVED VEHICLES, MAY BE IMPROPERLY CONNECTED. THIS CONDITION CAN CAUSE DAMAGE TO INTERNAL COMPONENTS.
Consequences:
Remedy:
THE WIRING WILL BE RECONNECTED TO ENSURE PROPER FUNCTIONING OF IGNITION SYSTEM..
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 1,236
Summary:
ON THE INVOLVED VEHICLES, IMPROPER ROUTING OF THE HYDRAULIC BRAKE TUBE COULD CAUSE IT TO CHAFE AGAINST THE PARK BRAKE CABLES. EVENTUALLY, THE BRAKE TUBE MAY FAIL AND BRAKE FLUID LEAKAGE MAY OCCUR.
Consequences:
Remedy:
DEALER WILL REROUTE THE HYDRAULIC BRAKE TUBE, IF NECESSARY, WITHOUT CHARGE TO OWNER.
|
|
|
Used 1982 Chrysler Lebaron Recalls
Components: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Cars Affected: 500,000
Summary:
FRONT SUSPENSION CROSSMEMBER MAY CORRODE AND FAIL AT LOWER CONTROL ARM REAR PIVOT MOUNTS IF OPERATED WHERE SALT IS USED TO AID IN SNOW REMOVAL.
Consequences:
CONTROL ARM COULD DETACH FROM THE CROSSMEMBER, ADVERSELYAFFECTING DIRECTIONAL STABILITY, WHICH COULD RESULT IN AN ACCIDENT.
Remedy:
INSTALL ATTACHMENT REINFORCEMENT BRACKETS TO PREVENT CONTROL ARM DETACHMENT AS A RESULT OF CORROSION WEAKENING.
Components: SERVICE BRAKES, HYDRAULIC:FLUID
Cars Affected: 69
Summary:
THE BRAKE HYDRAULIC SYSTEM BAY BE EQUIPPED WITH BRAKE FLUID CONTAINING AN EXCESS OF WATER.
Consequences:
Remedy:
DEALER WILL REPLACE DEFECTIVE BRAKE FLUID WITHOUT CHARGE TO OWNER.
Components: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Cars Affected: 4,000
Summary:
CLAMP BOLTS INSTALLED ON CERTAIN VEHICLES MAY CONTAIN CRACKS. EVENTUALLY THESE BOLTS MAY BREAK THROUGH, CAUSING SEPARATION OF THE BALL JOINT FROM THE STEERING KNUCKLE.
Consequences:
Remedy:
DEALER WILL REPLACE BOTH BALL JOINT STUD CLAMP BOLTS WITHOUT CHARGE TO OWNER.
Components: VEHICLE SPEED CONTROL
Cars Affected: 150,000
Summary:
THE AUTOMATIC SPEED CONTROL SWITCH MAY STICK IN THE "RESUME" POSITION RESTRICTING RETURN MOVEMENT. THIS WILL NOT ALLOW THE NORMAL BRAKE PEDAL OPERATION TO DEACTIVATE THE SYSTEM.
Consequences:
Remedy:
THE SHIELD PORTION OF THE "RESUME" SLIDE LEVER IN THE SPEED CONTROL UNIT WILL BE REPLACED WITHOUT CHARGE.
|
|
|
Used 1981 Chrysler Lebaron Recalls
Components: VEHICLE SPEED CONTROL
Cars Affected: 150,000
Summary:
THE AUTOMATIC SPEED CONTROL SWITCH MAY STICK IN THE "RESUME" POSITION RESTRICTING RETURN MOVEMENT. THIS WILL NOT ALLOW THE NORMAL BRAKE PEDAL OPERATION TO DEACTIVATE THE SYSTEM.
Consequences:
Remedy:
THE SHIELD PORTION OF THE "RESUME" SLIDE LEVER IN THE SPEED CONTROL UNIT WILL BE REPLACED WITHOUT CHARGE.
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 30,000
Summary:
ENGINE MAY LOSE POWER OR STALL DUE TO CARBURETOR FLOODING. THIS IS CAUSED BY A POOR ELECTRICAL GROUND ON THE CARBURETOR FUEL BOWL VENT SOLENOID. VEHICLES MAY ALSO HAVE DRIVEABILITY PROBLEMS WHILE THE ENGINE IS WARMING UP IN COLD WEATHER. THESE PROBLEMS INCLUDE ENGINE MISSING, SAGS, AND HESITATION. THIS IS CAUSED BY A STICKING CARBURETOR OXYGEN FEEDBACK SOLENOID.
Consequences:
Remedy:
DEALER WILL INSPECT CARBURETOR AND IF NECESSARY, THE BOWL VENT SOLENOID WILL BE REPAIRED BY RESOLDERING (RECONNECTING) THE EXTERNAL ELECTRICAL CONNECTION FREE OF CHARGE. IF APPLICABLE, THE OXYGEN FEEDBACK SENSOR WILL BE REPLACED.
|
|
|
Used 1980 Chrysler Lebaron Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 6,617
Summary:
THE FRONT BRAKE HOSE ROUTING ON THE INVOLVED VEHICLES MAY ALLOW INTERFERENCE BETWEEN THE HOSES AND THE FRONT TIRES DURING EXTREME TURNING ANGLES.
Consequences:
Remedy:
SPECIAL BRAKE HOSE RESTRAINING STRAPS WILL BE INSTALLED ON EACH INVOLVED VEHICLE TO RELOCATE BOTH FRONT HOSES AND ENSURE THAT ADEQUATE HOSE TO TIRE CLEARANCE IS MAINTAINED.
|
|
|
