 |
Used 2008 Dodge Sprinter 2500 Recalls
Components: SUSPENSION:REAR:SPRINGS
Cars Affected: 246
Summary:
SPRINTER IS RECALLING 246 MY 2008 DODGE OR FREIGHTLINER 2500 TRUCKS. THE REAR AXLE SPRING LEAVES WERE PRODUCED WITH AN INCORRECT RAW MATERIAL. THEREFORE THE LEAVES ARE THICKER THAN THE SERIAL COMPONENTS.
Consequences:
THE REAR AXLE SPRINGS MAY FAIL EARLIER THAN DESIGNED INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE REAR AXLE SPRINGS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 3, 2008. OWNERS MAY CONTACT SPRINTER AT 1-843-695-5000.
Components: STRUCTURE
Cars Affected: 727
Summary:
CHRYSLER/SPRINTER IS RECALLING 727 MY 2007-2008 DODGE AND FREIGHTLINER SPRINTER 2500 PASSENGER VANS EQUIPPED WITH 144 INCH WHEELBASE AND STANDARD ROOF HEIGHT. THESE VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201U, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' SOME VANS MAY NOT HAVE HAD CERTAIN HEAD IMPACT PROTECTION PADS INSTALLED AT THE C-PILLAR.
Consequences:
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy:
DEALERS WILL INSPECT THE VEHICLES AND, IF THE HEAD IMPACT PROTECTION PADS ARE MISSING, THE APPROPRIATE PADS WILL BE INSTALLED. THE RECALL BEGAN ON APRIL 9, 2008. OWNERS MAY CONTACT SPRINTER AT 1-800-853-1403.
|
|
 |
Used 2007 Dodge Sprinter 2500 Recalls
Components: STRUCTURE
Cars Affected: 727
Summary:
CHRYSLER/SPRINTER IS RECALLING 727 MY 2007-2008 DODGE AND FREIGHTLINER SPRINTER 2500 PASSENGER VANS EQUIPPED WITH 144 INCH WHEELBASE AND STANDARD ROOF HEIGHT. THESE VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201U, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' SOME VANS MAY NOT HAVE HAD CERTAIN HEAD IMPACT PROTECTION PADS INSTALLED AT THE C-PILLAR.
Consequences:
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy:
DEALERS WILL INSPECT THE VEHICLES AND, IF THE HEAD IMPACT PROTECTION PADS ARE MISSING, THE APPROPRIATE PADS WILL BE INSTALLED. THE RECALL BEGAN ON APRIL 9, 2008. OWNERS MAY CONTACT SPRINTER AT 1-800-853-1403.
Components: ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Cars Affected: 6,101
Summary:
ON CERTAIN UTILITY VANS, THE CRANKSHAFT SENSOR IN CERTAIN DIESEL ENGINES COULD FAIL DUE TO SEPARATION OF BOND WIRES FROM THE LEAD FRAME IN THE SENSOR. THIS RESULTS IN AN INTERRUPTION IN THE ELECTRICAL CONNECTION IN THE CHIP HOUSING OF THE SENSOR.
Consequences:
WHEN THIS HAPPENS, THE VEHICLES MAY LOSE POWER RATHER THAN ENTER A LIMP-HOME MODE. IN ADDITION, THE VEHICLE CANNOT BE RESTARTED AFTER FAILURE OF THE ELECTRICAL CONNECTION IN THE SENSOR, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL REPLACE THE CRANKSHAFT SENSORS. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT SPRINTER AT 1-800-992-1997.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOU...
Cars Affected: 461
Summary:
ON CERTAIN TRUCKS, THE SCREW BOLTS OF THE FUEL TANK FASTENING STRAPS MAY NOT HAVE BEEN TIGHTENED CORRECTLY. AFTER NORMAL PRODUCTION PROCESS, THE VEHICLES ARE DISASSEMBED FOR SHIPMENT TO THE US AND THE BOLTS MAY NOT HAVE BEEN CORRECTLY TIGHTENED WHEN RE-ASSEMBLED.
Consequences:
THE FUEL TANK CAN LOOSEN AND LEAK FUEL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy:
DEALERS WILL REPLACE THE SCREW BOLTS OF THE TANK FASTENING STRAPS AND THE BOLTS WILL BE TIGHTENED WITH THE CORRECT TORQUE. THE RECALL BEGAN ON OCTOBER 8, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER INTERNATIONAL AT 843-695-5041.
|
|
 |
Used 2006 Dodge Sprinter 2500 Recalls
Components: EQUIPMENT ADAPTIVE
Cars Affected: 3
Summary:
ILDERTON CONVERSION IS RECALLING 3 MY 2006 DODGE SPRINTER 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequences:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy:
ILDERTON CONVERSION IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ILDERTON CONVERSION AT 1-800-859-6066.
Components: EQUIPMENT ADAPTIVE
Cars Affected: 3
Summary:
ILDERTON CONVERSION IS RECALLING 3 MY 2006 SPRINTER DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequences:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy:
ILDERTON CONVERSION IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ILDERTON CONVERSION AT 1-800-859-6066.
Components: STEERING:COLUMN
Cars Affected: 10
Summary:
SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.
Consequences:
THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
Components: INTERIOR LIGHTING
Cars Affected: 4,433
Summary:
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.
Consequences:
THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.
Remedy:
DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
|
|
 |
Used 2005 Dodge Sprinter 2500 Recalls
Components: STEERING:COLUMN
Cars Affected: 10
Summary:
SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.
Consequences:
THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
Components: INTERIOR LIGHTING
Cars Affected: 4,433
Summary:
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.
Consequences:
THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.
Remedy:
DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
|
|
 |
Used 2004 Dodge Sprinter 2500 Recalls
Components: STEERING:COLUMN
Cars Affected: 10
Summary:
SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.
Consequences:
THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
Components: INTERIOR LIGHTING
Cars Affected: 4,433
Summary:
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.
Consequences:
THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.
Remedy:
DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
|
|
 |
Used 2003 Dodge Sprinter 2500 Recalls
Components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Cars Affected: 13,509
Summary:
SPRINTER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2003 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.
Consequences:
INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FRONT WALL.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 843-695-5031.
Components: STEERING:COLUMN
Cars Affected: 10
Summary:
SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.
Consequences:
THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
Components: INTERIOR LIGHTING
Cars Affected: 4,433
Summary:
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.
Consequences:
THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.
Remedy:
DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
|
|
|
