 |
Used 1979 Ford F-100 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Components: WHEELS
Cars Affected: 40,000
Summary:
A NUMBER OF WHEEL ASSEMBLIES ON THE INVOLVED VEHICLES MAY HAVE SUBSTANDARD WELDS IN THE AREA WHERE THE DISC IS ATTACHED TO THE RIM. SUBSTANDARD WELDS CAN CAUSE CRACKS TO OCCUR IN THE WHEEL ASSEMBLY. RAPID LOSS OF AIR PRESSURE IN THE TIRE OR SEPARATION OF THE WHEEL RIM FROM THE DISC COULD RESULT.
Consequences:
Remedy:
IF SEPARATION AND LOSS OF AIR OCCURS WHILE VEHICLE IS IN OPERATION, LOSS OF VEHICLE CONTROL AND AN ACCIDENT COULD OCCUR WITHOUT PRIOR WARNING. CORRECTIVE ACTION: THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE WHEELS WITHOUT CHARGE TO OWNER.
Components: WHEELS
Cars Affected: 22,500
Summary:
THE WHEEL ASSEMBLY MAY CONTAIN SUBSTANDARD WELDS IN THE AREA WHERE THE DISC IS ATTACHED TO THE RIM. AS A RESULT, CRACKS CAN FORM IN THE WHEEL ASSEMBLY, CAUSING AIR LOSS AND AN UNDERINFLATED TIRE.
Consequences:
Remedy:
DEALER WILL INSPECT AND REPLACE ANY DEFECTIVE WHEELS WITHOUT CHARGE TO OWNER.
Components: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
Cars Affected: 82,000
Summary:
THE INVOLVED VEHICLES WERE PRODUCED WITH BRAKE PUSH-ROD TO BRAKE PEDAL RETAINING PINS WHICH WERE NOT HEAT-TREATED AS SPECIFIED. THIS COULD ALLOW THE BRAKE PEDAL TO BECOME DISENGAGED FROM THE PUSH-ROD.
Consequences:
Remedy:
DEALER WILL REPLACE THE SUSPECT BRAKE RETAINING PIN.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOU...
Cars Affected: 105
Summary:
THE INVOLVED VEHICLES WERE MANUFACTURED WITHOUT A FUEL TANK SHIELD AT THE FRONT RIGHT CORNER OF THE MIDSHIP FUEL TANK. AS A RESULT, THE VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A VEHICLE ACCIDENT, EXCESSIVE FUEL SPILLAGE COULD RESULT.
Consequences:
Remedy:
THE DEALER WILL INSTALL THE REQUIRED FUEL TANK SHIELD WITHOUT CHARGE TO OWNER.
Components: VISIBILITY:WINDSHIELD
Cars Affected: 12
Summary:
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING", IN THAT SOME OF THE VEHICLES WERE BUILT WITHOUT THE SPECIFIED WINDSHIELD WEATHERSTRIP RETAINING COMPONENTS.
Consequences:
Remedy:
THE DEALER WILL INSTALL THE WINDSHIELD WEATHERSTRIP RETAINING COMPONENTS AT NO COST TO OWNER.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 7,000
Summary:
THE INVOLVED VEHICLES WERE EQUIPPED WITH AUTOMATIC TRANSMISSIONS IN WHICH THE PARKING PAWL WAS NOT HEAT-TREATED. DURING NORMAL VEHICLE OPERATION, A PARKING PAWL THAT HAS NOT BEEN HEAT-TREATED COULD BECOME DEFORMED OR WORN TO THE POINT THAT THE TRANSMISSION WILL NOT LOCK IN "PARK". AS A RESULT, THE VEHICLE COULD ROLL FREE IF THE DRIVER DOES NOT SET THE PARKING BRAKE WHEN PARKING OR LEAVING VEHICLE UNATTENDED.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL WITH ONE THAT HAS BEEN HEAT-TREATED.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 22,000
Summary:
THESE TRANSMISSIONS MAY CONTAIN IMPROPERLY MANUFACTURED PARKING PAWL ACTUATING RODS. CONSEQUENTLY, THE UNHARDENED CAM SURFACE OF THESE RODS CAN ALLOW THE ROD TO DEFORM DURING USE WITH RESULTANT INCREASE IN SHIFT EFFORTS AND DIFFICULTY IN RELEASING THE PARKING PAWL AND ENGAGING THE PARKING GEAR.
Consequences:
Remedy:
DEALER WILL REPLACE THE TRANSMISSION PARKING PAWL ACTUATING ROD WITHOUT CHARGE TO OWNER.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOU...
Cars Affected: 103
Summary:
THE INVOLVED VEHICLES DO NOT CONTAIN A FUEL TANK SHIELD AT THE FRONT RIGHT CORNER OF THE MID-SHIP FUEL TANK. IN THE EVENT OF A FRONTAL IMPACT, EXCESSIVE FUEL SPILLAGE FROM THE FUEL TANK MAY OCCUR. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY".
Consequences:
Remedy:
DEALER WILL INSTALL THE NECESSARY FUEL TANK SHIELD WITHOUT CHARGE TO OWNER.
|
|
|
Used 1978 Ford F-100 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Components: SEAT BELTS:FRONT:RETRACTOR
Cars Affected: 7
Summary:
THE DRIVER"S SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ASSEMBLY CONTAINS A WELD NUT WHICH WAS IMPROPERLY ATTACHED TO THE BRACKET. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".
Consequences:
Remedy:
THE DEALER WILL REPAIR THE LEFT SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ON THE INVOLVED VEHICLES FREE OF CHARGE.
Components: STEERING:LINKAGES
Cars Affected: 77
Summary:
THESE VEHICLES MAY BE EQUIPPED WITH STEERING LINKAGES ON WHICH COTTER PINS MAY NOT HAVE BEEN INSTALLED ON CASTELLATED NUTS TO SECURE THE STEERING DRAG LINK AND TIE-ROD CONNECTIONS. ALSO, THESE ATTACHING NUTS MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATIONS. THIS COULD ALLOW LINKAGE SEPARATION.
Consequences:
Remedy:
THE DEALER WILL PERFORM NECESSARY CORRECTIONS TO THE STEERING LINKAGE ATTACHMENTS.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LI...
Cars Affected: 47,339
Summary:
THE SHIFT SELECTOR REACTION SPRINGS MAY BE DEFORMED AS A RESULT OF IMPROPER INSTALLATION OF SELECTOR LEVERS DURING COLUMN BUILDUP. THUS THE LEVER MAY NOT BE ABLE TO BE MOVED INTO THE INSERT DETENTS LOCATED IN THE STEERING COLUMN ASSEMBLY. THIS COULD PREVENT THE "PARK" GEAR FROM BEING ENGAGED.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE SHIFT SELECTOR REACTION SPRING WITHOUT CHARGE TO OWNER.
Components: WHEELS
Cars Affected: 17,000
Summary:
SOME OF THE STEEL WHEELS ON THE INVOLVED VEHICLES MAY HAVE BEEN IMPROPERLY MANUFACTURED. THESE WHEELS, OVER A PERIOD OF TIME, COULD CRACK IN THE WHEEL RIM AREA THROUGH NORMAL OPERATION, WITHOUT PRIOR WARNING.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE WHEELS ON THE INVOLVED VEHICLES.
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 30,000
Summary:
ON THE INVOLVED VEHICLES, LEAKAGE MAY OCCUR AT THE THREADED CARBURETOR-TO-FUEL FILTER CONNECTION ON THE SUSPECT CARBURETORS. THIS IS DUE TO AN IMPROPERLY MACHINED CARBURETOR FUEL INLET CONNECTION.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE THE CARBURETOR WITHOUT CHARGE TO OWNER.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LI...
Cars Affected: 19,000
Summary:
ON THE INVOLVED VEHICLES, THE PARK ACTUATION SUPPORT PLATES ARE DEFECTIVE DUE TO THEIR SUSCEPTIBILITY TO CRACKING DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. AS A RESULT, FRAGMENTS FROM A BROKEN PLATE CAN BECOME LODGED IN THE TRANSMISSION PARKING PAWL MECHANISM. THIS COULD PREVENT THE TRANSMISSION PARKING PAWL FROM ENGAGING WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION, OR PREVENT THE PAWL FROM BEING DISENGAGED FROM THE PARK GEAR.
Consequences:
Remedy:
THE DEALER WILL REPLACE THE PARK ACTUATION CAM SUPPORT PLATES, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.
Components: STEERING:LINKAGES
Cars Affected: 13,707
Summary:
THE PITMAN ARM TO STEERING GEAR ATTACHMENT NUTS MAY NOT HAVE BEEN PROPERLY TIGHTENED ON THE INVOLVED VEHICLES. THE NUT COULD COME OFF DURING VEHICLE OPERATION.
Consequences:
Remedy:
DEALER WILL TIGHTEN THE PITMAN ARM ATTACHING NUT TO THE CORRECT SPECIFICATIONS WITHOUT CHARGE TO OWNER.
|
|
|
Used 1977 Ford F-100 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 40,000
Summary:
ON THE INVOLVED VEHICLES, THE MANUAL STEERING GEARS MAY CONTAIN STEERING GEAR RECIRCULATORY BALLS THAT COULD FRACTURE. THIS FRACTURING IS A RESULT OF IMPROPER HEAT-TREATMENT DURING MANUFACTURE AND CAN EVENTUALLY CAUSE INCREASED STEERING EFFORT.
Consequences:
Remedy:
THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BALL BEARINGS OF THE STEERING GEAR, WITHOUT CHARGE TO OWNER.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 60,000
Summary:
THE INVOLVED VEHICLES MAY EXPERIENCE FUEL LEAKAGE AT THE RUBBER HOSE CONNECTING THE FUEL INLET TUBE TO THE CARBURETOR FILTER. THIS LEAKAGE CONDITION IS DUE TO INSUFFICIENT INSERTION OF THE FUEL TUBE INTO THE HOSE OR IMPROPER POSITIONING OF THE HOSE CLAMP, CAUSING THE CLAMP TO BE CRIMPED DIRECTLY OVER THE FUEL TUBE BEAD.
Consequences:
Remedy:
DEALER WILL REPLACE THE EXISTING FUEL HOSE CLAMP WITH A SPRING-TYPE CLAMP AT THE HOSE-TO-FUEL INLET TUBE CONNECTION, AND ADJUST THE CONNECTION WHERE NECESSARY, WITHOUT CHARGE.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOU...
Cars Affected: 11
Summary:
THE UPPER SUPPORT STRAP NUTS, ATTACHING THE FUEL TANK, WERE NOT TIGHTENED TO SPECIFICATIONS. THIS MAY ALLOW THE FUEL TANK TO DETACH AND FALL TO THE GROUND.
Consequences:
Remedy:
DEALER WILL TIGHTEN ATTACHING NUTS TO PROPER SPECIFICATIONS TO SECURE THE FUEL TANK, AT NO COST TO OWNER.
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 12,500
Summary:
Consequences:
Remedy:
|
|
|
Used 1976 Ford F-100 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Components: SERVICE BRAKES, HYDRAULIC:POWER ASSIST
Cars Affected: 101
Summary:
Consequences:
Remedy:
|
|
|
Used 1975 Ford F-100 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
|
|
|
Used 1974 Ford F-100 Pickup Recalls
Components: TIRES:TREAD/BELT
Cars Affected: 35,711
Summary:
Consequences:
Remedy:
Components: SEATS:FRONT ASSEMBLY:RECLINER
Cars Affected: 3,080
Summary:
Consequences:
Remedy:
|
|
|
Used 1973 Ford F-100 Pickup Recalls
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 11,301
Summary:
Consequences:
Remedy:
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 7,441
Summary:
Consequences:
Remedy:
Components: STEERING:HYDRAULIC POWER ASSIST SYSTEM
Cars Affected: 128
Summary:
Consequences:
Remedy:
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 1,033,800
Summary:
Consequences:
Remedy:
|
|
|
Used 1972 Ford F-100 Pickup Recalls
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 1,033,800
Summary:
Consequences:
Remedy:
Components: SUSPENSION:FRONT:WHEEL BEARING
Cars Affected: 1,950
Summary:
Consequences:
Remedy:
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 28,459
Summary:
Consequences:
Remedy:
|
|
|
Used 1971 Ford F-100 Pickup Recalls
Components: TIRES:TREAD/BELT
Cars Affected: 6,000
Summary:
Consequences:
Remedy:
|
|
|
Used 1970 Ford F-100 Pickup Recalls
Components: TIRES:TREAD/BELT
Cars Affected: 6,000
Summary:
Consequences:
Remedy:
|
|
|
Used 1969 Ford F-100 Pickup Recalls
Components: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Cars Affected: 80,700
Summary:
Consequences:
Remedy:
|
|
|
Used 1967 Ford F-100 Pickup Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 3,500
Summary:
Consequences:
Remedy:
|
|
|
