 |
Used 1979 Ford F-350 Pickup Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 34,000
Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequences:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Components: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
Cars Affected: 82,000
Summary:
THE INVOLVED VEHICLES WERE PRODUCED WITH BRAKE PUSH-ROD TO BRAKE PEDAL RETAINING PINS WHICH WERE NOT HEAT-TREATED AS SPECIFIED. THIS COULD ALLOW THE BRAKE PEDAL TO BECOME DISENGAGED FROM THE PUSH-ROD.
Consequences:
Remedy:
DEALER WILL REPLACE THE SUSPECT BRAKE RETAINING PIN.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 7,000
Summary:
THE INVOLVED VEHICLES WERE EQUIPPED WITH AUTOMATIC TRANSMISSIONS IN WHICH THE PARKING PAWL WAS NOT HEAT-TREATED. DURING NORMAL VEHICLE OPERATION, A PARKING PAWL THAT HAS NOT BEEN HEAT-TREATED COULD BECOME DEFORMED OR WORN TO THE POINT THAT THE TRANSMISSION WILL NOT LOCK IN "PARK". AS A RESULT, THE VEHICLE COULD ROLL FREE IF THE DRIVER DOES NOT SET THE PARKING BRAKE WHEN PARKING OR LEAVING VEHICLE UNATTENDED.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL WITH ONE THAT HAS BEEN HEAT-TREATED.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 22,000
Summary:
THESE TRANSMISSIONS MAY CONTAIN IMPROPERLY MANUFACTURED PARKING PAWL ACTUATING RODS. CONSEQUENTLY, THE UNHARDENED CAM SURFACE OF THESE RODS CAN ALLOW THE ROD TO DEFORM DURING USE WITH RESULTANT INCREASE IN SHIFT EFFORTS AND DIFFICULTY IN RELEASING THE PARKING PAWL AND ENGAGING THE PARKING GEAR.
Consequences:
Remedy:
DEALER WILL REPLACE THE TRANSMISSION PARKING PAWL ACTUATING ROD WITHOUT CHARGE TO OWNER.
|
|
|
Used 1978 Ford F-350 Pickup Recalls
Components: SEAT BELTS:FRONT:RETRACTOR
Cars Affected: 7
Summary:
THE DRIVER"S SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ASSEMBLY CONTAINS A WELD NUT WHICH WAS IMPROPERLY ATTACHED TO THE BRACKET. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".
Consequences:
Remedy:
THE DEALER WILL REPAIR THE LEFT SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ON THE INVOLVED VEHICLES FREE OF CHARGE.
Components: STEERING:LINKAGES
Cars Affected: 77
Summary:
THESE VEHICLES MAY BE EQUIPPED WITH STEERING LINKAGES ON WHICH COTTER PINS MAY NOT HAVE BEEN INSTALLED ON CASTELLATED NUTS TO SECURE THE STEERING DRAG LINK AND TIE-ROD CONNECTIONS. ALSO, THESE ATTACHING NUTS MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATIONS. THIS COULD ALLOW LINKAGE SEPARATION.
Consequences:
Remedy:
THE DEALER WILL PERFORM NECESSARY CORRECTIONS TO THE STEERING LINKAGE ATTACHMENTS.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LI...
Cars Affected: 47,339
Summary:
THE SHIFT SELECTOR REACTION SPRINGS MAY BE DEFORMED AS A RESULT OF IMPROPER INSTALLATION OF SELECTOR LEVERS DURING COLUMN BUILDUP. THUS THE LEVER MAY NOT BE ABLE TO BE MOVED INTO THE INSERT DETENTS LOCATED IN THE STEERING COLUMN ASSEMBLY. THIS COULD PREVENT THE "PARK" GEAR FROM BEING ENGAGED.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE SHIFT SELECTOR REACTION SPRING WITHOUT CHARGE TO OWNER.
Components: WHEELS:MULTI PIECE
Cars Affected: 9,000
Summary:
THE WHEEL RIM DIAMETERS ON THESE VEHICLES MAY EXCEED DIMENSIONAL SPECIFICATIONS. THIS MAY CAUSE THE TIRES AND TUBES TO BE OVERSTRESSED DURING MOUNTING OR IMPROPERLY MOUNTED.
Consequences:
Remedy:
THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE WHEELS, AND THE TIRES AND TUBES MOUNTED ON THESE WHEELS.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Cars Affected: 2
Summary:
THE INVOLVED VEHICLES WERE BUILT WITH AFT-OF-AXLE FUEL TANKS WHICH WERE NOT AUTHORIZED BY LIGHT TRUCK ENGINEERING. AS A RESULT, THESE VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY", DUE TO POSSIBLE FUEL TANK LEAKAGE WHEN IMPACTED FROM THE REAR.
Consequences:
Remedy:
DEALER WILL INSPECT AND REPLACE AFT-OF-AXLE FUEL TANK WITH THE CORRECT TANK, WITHOUT CHARGE TO OWNER.
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 30,000
Summary:
ON THE INVOLVED VEHICLES, LEAKAGE MAY OCCUR AT THE THREADED CARBURETOR-TO-FUEL FILTER CONNECTION ON THE SUSPECT CARBURETORS. THIS IS DUE TO AN IMPROPERLY MACHINED CARBURETOR FUEL INLET CONNECTION.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE THE CARBURETOR WITHOUT CHARGE TO OWNER.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LI...
Cars Affected: 19,000
Summary:
ON THE INVOLVED VEHICLES, THE PARK ACTUATION SUPPORT PLATES ARE DEFECTIVE DUE TO THEIR SUSCEPTIBILITY TO CRACKING DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. AS A RESULT, FRAGMENTS FROM A BROKEN PLATE CAN BECOME LODGED IN THE TRANSMISSION PARKING PAWL MECHANISM. THIS COULD PREVENT THE TRANSMISSION PARKING PAWL FROM ENGAGING WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION, OR PREVENT THE PAWL FROM BEING DISENGAGED FROM THE PARK GEAR.
Consequences:
Remedy:
THE DEALER WILL REPLACE THE PARK ACTUATION CAM SUPPORT PLATES, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.
Components: STEERING:LINKAGES
Cars Affected: 13,707
Summary:
THE PITMAN ARM TO STEERING GEAR ATTACHMENT NUTS MAY NOT HAVE BEEN PROPERLY TIGHTENED ON THE INVOLVED VEHICLES. THE NUT COULD COME OFF DURING VEHICLE OPERATION.
Consequences:
Remedy:
DEALER WILL TIGHTEN THE PITMAN ARM ATTACHING NUT TO THE CORRECT SPECIFICATIONS WITHOUT CHARGE TO OWNER.
Components: VEHICLE SPEED CONTROL
Cars Affected: 16,000
Summary:
SOME OF THE INVOLVED VEHICLES MAY HAVE DEFECTIVE CARBURETORS IN WHICH, UNDER CERTAIN CIRCUMSTANCES, THE SECONDARY THROTTLE PLATES MAY STICK OPEN.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE CARBURETOR AT NO CHARGE TO OWNER.
|
|
|
Used 1977 Ford F-350 Pickup Recalls
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 40,000
Summary:
ON THE INVOLVED VEHICLES, THE MANUAL STEERING GEARS MAY CONTAIN STEERING GEAR RECIRCULATORY BALLS THAT COULD FRACTURE. THIS FRACTURING IS A RESULT OF IMPROPER HEAT-TREATMENT DURING MANUFACTURE AND CAN EVENTUALLY CAUSE INCREASED STEERING EFFORT.
Consequences:
Remedy:
THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BALL BEARINGS OF THE STEERING GEAR, WITHOUT CHARGE TO OWNER.
Components: VEHICLE SPEED CONTROL
Cars Affected: 16,000
Summary:
SOME OF THE INVOLVED VEHICLES MAY HAVE DEFECTIVE CARBURETORS IN WHICH, UNDER CERTAIN CIRCUMSTANCES, THE SECONDARY THROTTLE PLATES MAY STICK OPEN.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE CARBURETOR AT NO CHARGE TO OWNER.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 60,000
Summary:
THE INVOLVED VEHICLES MAY EXPERIENCE FUEL LEAKAGE AT THE RUBBER HOSE CONNECTING THE FUEL INLET TUBE TO THE CARBURETOR FILTER. THIS LEAKAGE CONDITION IS DUE TO INSUFFICIENT INSERTION OF THE FUEL TUBE INTO THE HOSE OR IMPROPER POSITIONING OF THE HOSE CLAMP, CAUSING THE CLAMP TO BE CRIMPED DIRECTLY OVER THE FUEL TUBE BEAD.
Consequences:
Remedy:
DEALER WILL REPLACE THE EXISTING FUEL HOSE CLAMP WITH A SPRING-TYPE CLAMP AT THE HOSE-TO-FUEL INLET TUBE CONNECTION, AND ADJUST THE CONNECTION WHERE NECESSARY, WITHOUT CHARGE.
|
|
|
Used 1976 Ford F-350 Pickup Recalls
Components: SERVICE BRAKES, HYDRAULIC:POWER ASSIST
Cars Affected: 101
Summary:
Consequences:
Remedy:
|
|
|
Used 1975 Ford F-350 Pickup Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 42,096
Summary:
Consequences:
Remedy:
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 2,709
Summary:
Consequences:
Remedy:
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 140,870
Summary:
Consequences:
Remedy:
Components: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Cars Affected: 140,870
Summary:
Consequences:
Remedy:
|
|
|
Used 1974 Ford F-350 Pickup Recalls
Components: SEATS:FRONT ASSEMBLY:RECLINER
Cars Affected: 3,080
Summary:
Consequences:
Remedy:
|
|
|
Used 1973 Ford F-350 Pickup Recalls
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 11,301
Summary:
Consequences:
Remedy:
Components: STEERING:HYDRAULIC POWER ASSIST SYSTEM
Cars Affected: 128
Summary:
Consequences:
Remedy:
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 1,033,800
Summary:
Consequences:
Remedy:
|
|
|
Used 1972 Ford F-350 Pickup Recalls
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 1,033,800
Summary:
Consequences:
Remedy:
Components: SUSPENSION:FRONT:WHEEL BEARING
Cars Affected: 1,950
Summary:
Consequences:
Remedy:
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 28,459
Summary:
Consequences:
Remedy:
|
|
|
Used 1969 Ford F-350 Pickup Recalls
Components: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Cars Affected: 80,700
Summary:
Consequences:
Remedy:
|
|
|
Used 1968 Ford F-350 Pickup Recalls
Components: STRUCTURE:BODY
Cars Affected: 13,490
Summary:
Consequences:
Remedy:
Components: EXTERIOR LIGHTING
Cars Affected: 160
Summary:
Consequences:
Remedy:
|
|
|
Used 1967 Ford F-350 Pickup Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 3,500
Summary:
Consequences:
Remedy:
|
|
|
