Isuzu Trooper Recalls
Vehicle manufacturers issue official Isuzu Trooper recall notices to inform car owners of problems and/or defects that have been brought to the manufacturer's attention. An automotive recall requires the manufacturer to send an official notice to owners of the vehicles found to be defective once the NHTSA deems the problem to be wide spread and an official Isuzu Trooper recall. View listings of Isuzu Trooper recalls from NHTSA below with full details, vehicles affected, date reported, and more.
|
|
 |
Used 2001 Isuzu Trooper Recalls
Components: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
Cars Affected: 18,462
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE AND AUTOMATIC TRANSMISSIONS BUILT WITH TOD (TORQUE-ON-DEMAND). IN CERTAIN HIGH SPEED, FRONTAL CRASHES, MOVEMENT OF ENGINE COMPARTMENT COMPONENTS CAN CAUSE THE POTENTIAL FOR FUEL LEAKAGE.
Consequences:
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL INSTALL A NEW, REINFORCED FUEL HOSE ASSEMBLY. NOTE: THE FUEL LEAKAGE ISSUE IN THIS RECALL CAMPAIGN IS NOT THE SAME AS THE ONE ADDRESSED IN THEIR PREVIOUS CAMPAIGN 00V-253.
|
|
 |
Used 2000 Isuzu Trooper Recalls
Components: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
Cars Affected: 18,462
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE AND AUTOMATIC TRANSMISSIONS BUILT WITH TOD (TORQUE-ON-DEMAND). IN CERTAIN HIGH SPEED, FRONTAL CRASHES, MOVEMENT OF ENGINE COMPARTMENT COMPONENTS CAN CAUSE THE POTENTIAL FOR FUEL LEAKAGE.
Consequences:
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL INSTALL A NEW, REINFORCED FUEL HOSE ASSEMBLY. NOTE: THE FUEL LEAKAGE ISSUE IN THIS RECALL CAMPAIGN IS NOT THE SAME AS THE ONE ADDRESSED IN THEIR PREVIOUS CAMPAIGN 00V-253.
Components: FUEL SYSTEM, GASOLINE:DELIVERY
Cars Affected: 13,275
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE AND AUTOMATIC TRANSMISSIONS BUILT WITH TOD (TORQUE-ON-DEMAND). IN CERTAIN HIGH SPEED FRONTAL CRASHES, AN INTERIOR FUEL LINE AND FUEL HOSE CAN BE SEPARATED, ALLOWING FUEL TO LEAK.
Consequences:
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL INSTALL FUEL SYSTEM SHIELDS.
|
|
 |
Used 1998 Isuzu Trooper Recalls
Components: POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Cars Affected: 3,062
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE TRANSFER GEARBOX FLANGE NUTS WERE NOT PROPERLY INSTALLED, CAUSING THE NUTS TO LOOSEN.
Consequences:
IF THE FLANGE NUTS LOOSEN, THE PROPELLER SHAFT CAN SEPARATE, RENDERING THE VEHICLE INOPEATIVE.
Remedy:
DEALERS WILL INSPECT FRONT AND REAR FLANGE NUTS AND, IF FOUND LOOSE, TIGHTEN TO SPECIFIED TORQUE AND SECURED STAKED AT TWO PLACES.
|
|
 |
Used 1997 Isuzu Trooper Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 6,667
Summary:
THE LEFT FRONT BRAKE LINES WERE INSTALLED IMPROPERLY AT THE ASSEMBLY LINE RESULTING IN INSUFFICIENT CLEARANCE BETWEEN THE BRAKE LINE AND AN UPPER CONTROL ARM OF THE SUSPENSION.
Consequences:
THE LINE CAN BE DAMAGED DURING VEHICLE OPERATION AND CAN RESULT IN BRAKE FLUID LEAKAGE, REDUCED BRAKE EFFECTIVENESS, AND INCREASED STOPPING DISTANCES.
Remedy:
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE BRAKE LINE AND THE UPPER CONTROL ARM. IF THE CLEARANCE IS NOT ACCORDING TO SPECIFICATIONS, THE BRAKE LINE WILL BE REPLACED.
Components: SUSPENSION
Cars Affected: 270
Summary:
THESE VEHICLES WERE MANUFACTURED WITHOUT A LOCK WASHER AND/OR SCREWS IN THE FRONT HUB.
Consequences:
THE BEARING ADJUSTMENT NUT CAN LOOSEN, RESULTING IN TOO MUCH FREE PLAY BETWEEN THE WHEEL AND AXLE. THE BEARING CAN SEIZE, CAUSING THE WHEEL TO LOCK AFFECTING VEHICLE DIRECTIONAL CONTROL INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT THE FRONT HUBS TO DETERMINE IF THE LOCK WASHER AND SCREWS WERE PROPERLY INSTALLED. IF NOT, THEY WILL MAKE THE NECESSARY REPAIRS.
|
|
|
Used 1996 Isuzu Trooper Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 6,667
Summary:
THE LEFT FRONT BRAKE LINES WERE INSTALLED IMPROPERLY AT THE ASSEMBLY LINE RESULTING IN INSUFFICIENT CLEARANCE BETWEEN THE BRAKE LINE AND AN UPPER CONTROL ARM OF THE SUSPENSION.
Consequences:
THE LINE CAN BE DAMAGED DURING VEHICLE OPERATION AND CAN RESULT IN BRAKE FLUID LEAKAGE, REDUCED BRAKE EFFECTIVENESS, AND INCREASED STOPPING DISTANCES.
Remedy:
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE BRAKE LINE AND THE UPPER CONTROL ARM. IF THE CLEARANCE IS NOT ACCORDING TO SPECIFICATIONS, THE BRAKE LINE WILL BE REPLACED.
Components: SEAT BELTS:REAR
Cars Affected: 2,345
Summary:
CERTAIN VEHICLES WERE MANUFACTURED WITH AN INCORRECT REAR CENTER SEAT BELT ASSEMBLY BUCKLE. THE MISBUILD INVOLVED FITTING A BUCKLE FOR ANOTHER MARKET WITH THE CORRECT U.S. SPECIFICATION SEAT BELT.
Consequences:
SUCH INSTALLATION RESULTS IN A REAR CENTER SEAT BELT ASSEMBLY IN WHICH THE BELT TONGUE CANNOT BE INSERTED INTO THE BUCKLE AND A CONSQUENT INABILITY OF THE SYSTEM TO PROVIDE PROPER OCCUPANT RESTRAINT DURING PANIC BRAKING OF THE VEHICLE OR AN ACCIDENT.
Remedy:
DEALERS WILL INSPECT THE REAR CENTER SEAT BELT TONGUE AND BUCKLE AND INCORRECT BUCKLE ASSEMBLIES WILL BE REPLACED.
|
|
|
Used 1995 Isuzu Trooper Recalls
Components: VEHICLE SPEED CONTROL:CABLES
Cars Affected: 72,905
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CAN STICK SO THAT THE ENGINE SPEED WILL NOT IMMEDIATELY DECREASE UPON RELEASE OF THE ACCELERATOR PEDAL.
Consequences:
THIS CAN CAUSE THE ACCELERATOR THROTTLE CABLE TO DELAY RPM AND VEHICLE SPEED REDUCTION FOR SEVERAL SECONDS AFTER THE ACCELERATOR PEDAL IS RELEASED, WHICH IN TURN, CAN LEAD TO A CRASH.
Remedy:
DEALERS WILL REPLACE THE THROTTLE CABLE RUBBER BOOT. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT ISUZU AT 1-800-255-6727.
|
|
|
Used 1994 Isuzu Trooper Recalls
Components: VEHICLE SPEED CONTROL:CABLES
Cars Affected: 72,905
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CAN STICK SO THAT THE ENGINE SPEED WILL NOT IMMEDIATELY DECREASE UPON RELEASE OF THE ACCELERATOR PEDAL.
Consequences:
THIS CAN CAUSE THE ACCELERATOR THROTTLE CABLE TO DELAY RPM AND VEHICLE SPEED REDUCTION FOR SEVERAL SECONDS AFTER THE ACCELERATOR PEDAL IS RELEASED, WHICH IN TURN, CAN LEAD TO A CRASH.
Remedy:
DEALERS WILL REPLACE THE THROTTLE CABLE RUBBER BOOT. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT ISUZU AT 1-800-255-6727.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 122,297
Summary:
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequences:
THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy:
DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
|
|
|
Used 1993 Isuzu Trooper Recalls
Components: VEHICLE SPEED CONTROL:CABLES
Cars Affected: 72,905
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CAN STICK SO THAT THE ENGINE SPEED WILL NOT IMMEDIATELY DECREASE UPON RELEASE OF THE ACCELERATOR PEDAL.
Consequences:
THIS CAN CAUSE THE ACCELERATOR THROTTLE CABLE TO DELAY RPM AND VEHICLE SPEED REDUCTION FOR SEVERAL SECONDS AFTER THE ACCELERATOR PEDAL IS RELEASED, WHICH IN TURN, CAN LEAD TO A CRASH.
Remedy:
DEALERS WILL REPLACE THE THROTTLE CABLE RUBBER BOOT. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT ISUZU AT 1-800-255-6727.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 122,297
Summary:
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequences:
THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy:
DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
|
|
|
Used 1992 Isuzu Trooper Recalls
Components: VEHICLE SPEED CONTROL:CABLES
Cars Affected: 72,905
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CAN STICK SO THAT THE ENGINE SPEED WILL NOT IMMEDIATELY DECREASE UPON RELEASE OF THE ACCELERATOR PEDAL.
Consequences:
THIS CAN CAUSE THE ACCELERATOR THROTTLE CABLE TO DELAY RPM AND VEHICLE SPEED REDUCTION FOR SEVERAL SECONDS AFTER THE ACCELERATOR PEDAL IS RELEASED, WHICH IN TURN, CAN LEAD TO A CRASH.
Remedy:
DEALERS WILL REPLACE THE THROTTLE CABLE RUBBER BOOT. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT ISUZU AT 1-800-255-6727.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 122,297
Summary:
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequences:
THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy:
DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
|
|
|
Used 1991 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 17,048
Summary:
PUTTING IN MORE TRANSMISSION OIL THAN SPECIFIED CAN CAUSE OIL TO BLEED THROUGH AIR GROOVE ON TO THE EXHAUST MANIFOLD IF OIL TEMPERATURE RISES.
Consequences:
THIS COULD CAUSE SMOKE EMISSION FROM THE MANIFOLD, WHICHCOULD IGNITE RUBBER HOSES AND RESULT IN A FIRE.
Remedy:
REPLACE OIL LEVEL GAUGE AND NOTIFY OWNERS TO USE ONLY THE SPECIFIED AMOUNT OF AUTOMATIC TRANSMISSION FLUID.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
Cars Affected: 12,222
Summary:
IMPROPERLY INSTALLED HOSE ON THE OIL COOLER COULD COME IN CONTACT WITH THE EXHAUST MANIFOLD AND COULD MELT.
Consequences:
ENGINE OIL COULD LEAK OUT WITH POTENTIAL FOR ENGINESEIZURE AND DAMAGE AND COULD RESULT IN A FIRE.
Remedy:
PROPERLY INSTALL COOLER HOSE CLIP TO PREVENT CONTACT WITH EXHAUST MANIFOLD.
|
|
|
Used 1990 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 17,048
Summary:
PUTTING IN MORE TRANSMISSION OIL THAN SPECIFIED CAN CAUSE OIL TO BLEED THROUGH AIR GROOVE ON TO THE EXHAUST MANIFOLD IF OIL TEMPERATURE RISES.
Consequences:
THIS COULD CAUSE SMOKE EMISSION FROM THE MANIFOLD, WHICHCOULD IGNITE RUBBER HOSES AND RESULT IN A FIRE.
Remedy:
REPLACE OIL LEVEL GAUGE AND NOTIFY OWNERS TO USE ONLY THE SPECIFIED AMOUNT OF AUTOMATIC TRANSMISSION FLUID.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
Cars Affected: 12,222
Summary:
IMPROPERLY INSTALLED HOSE ON THE OIL COOLER COULD COME IN CONTACT WITH THE EXHAUST MANIFOLD AND COULD MELT.
Consequences:
ENGINE OIL COULD LEAK OUT WITH POTENTIAL FOR ENGINESEIZURE AND DAMAGE AND COULD RESULT IN A FIRE.
Remedy:
PROPERLY INSTALL COOLER HOSE CLIP TO PREVENT CONTACT WITH EXHAUST MANIFOLD.
|
|
|
Used 1989 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
|
|
|
Used 1988 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
Components: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
Cars Affected: 463
Summary:
DUE TO INSUFFICIENT CLEARANCE BETWEEN A BOLT THAT FIXES THE HEATER TO THE VEHICLE BODY AND A FUEL DELIVERY PIPE AND BETWEEN A REAR HEATER HOSE CLIP, USE UNDER SERVERE CONDITIONS COULD CAUSE PIPE RUPTURE AND FUEL LEAKAGE.
Consequences:
THIS COULD RESULT IN A FIRE.
Remedy:
INSTALL NEW LINES AND A CLIP.
|
|
|
Used 1987 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 49,300
Summary:
TRUCKS USED IN THE SALT-BELT STATES CAN HAVE ACCUMULATED CORROSION IN THE HINGES OF THE REAR DOORS. IF THE VEHICLES ALSO HAVE MISALIGNED DOOR LATCHES AND STRIKERS, IT IS POSSIBLE TO CLOSE THE DOORS IN A "FALSE LATCH" CONDITION.
Consequences:
IN THE "FALSE LATCH" CONDITION, THE REAR DOORS MAY GIVETHE IMPRESSION THAT THE DOOR IS PROPERLY LATCHED WHEN IT IS NOT. THIS COULD LEADTO PASSENGERS AND/OR CARGO FALLING FROM REAR DOORS WHICH CAN OPEN WITHOUT PRIORWARNING.
Remedy:
CHECK THE DOOR LATCHES AND STRIKERS FOR CORRECT ALIGNMENT AND REPAIR IF NECESSARY; ALSO INSPECT REAR DOOR HINGES FOR CORROSION AND REPLACE IF NECESSARY.
Components: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
Cars Affected: 463
Summary:
DUE TO INSUFFICIENT CLEARANCE BETWEEN A BOLT THAT FIXES THE HEATER TO THE VEHICLE BODY AND A FUEL DELIVERY PIPE AND BETWEEN A REAR HEATER HOSE CLIP, USE UNDER SERVERE CONDITIONS COULD CAUSE PIPE RUPTURE AND FUEL LEAKAGE.
Consequences:
THIS COULD RESULT IN A FIRE.
Remedy:
INSTALL NEW LINES AND A CLIP.
|
|
|
Used 1986 Isuzu Trooper Recalls
Components: TRAILER HITCHES
Cars Affected: 670
Summary:
THE WELD ON THE RECEIVER UNIT OF THE TRAILER HITCH CAN BREAK.
Consequences:
IF THE FAILURE OCCURS, THE TRAILER CAN SEPARATE FROM THETOWING VEHICLE, AND COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
REPLACE THE TRAILER HITCH.
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 49,300
Summary:
TRUCKS USED IN THE SALT-BELT STATES CAN HAVE ACCUMULATED CORROSION IN THE HINGES OF THE REAR DOORS. IF THE VEHICLES ALSO HAVE MISALIGNED DOOR LATCHES AND STRIKERS, IT IS POSSIBLE TO CLOSE THE DOORS IN A "FALSE LATCH" CONDITION.
Consequences:
IN THE "FALSE LATCH" CONDITION, THE REAR DOORS MAY GIVETHE IMPRESSION THAT THE DOOR IS PROPERLY LATCHED WHEN IT IS NOT. THIS COULD LEADTO PASSENGERS AND/OR CARGO FALLING FROM REAR DOORS WHICH CAN OPEN WITHOUT PRIORWARNING.
Remedy:
CHECK THE DOOR LATCHES AND STRIKERS FOR CORRECT ALIGNMENT AND REPAIR IF NECESSARY; ALSO INSPECT REAR DOOR HINGES FOR CORROSION AND REPLACE IF NECESSARY.
|
|
|
Used 1985 Isuzu Trooper Recalls
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 49,300
Summary:
TRUCKS USED IN THE SALT-BELT STATES CAN HAVE ACCUMULATED CORROSION IN THE HINGES OF THE REAR DOORS. IF THE VEHICLES ALSO HAVE MISALIGNED DOOR LATCHES AND STRIKERS, IT IS POSSIBLE TO CLOSE THE DOORS IN A "FALSE LATCH" CONDITION.
Consequences:
IN THE "FALSE LATCH" CONDITION, THE REAR DOORS MAY GIVETHE IMPRESSION THAT THE DOOR IS PROPERLY LATCHED WHEN IT IS NOT. THIS COULD LEADTO PASSENGERS AND/OR CARGO FALLING FROM REAR DOORS WHICH CAN OPEN WITHOUT PRIORWARNING.
Remedy:
CHECK THE DOOR LATCHES AND STRIKERS FOR CORRECT ALIGNMENT AND REPAIR IF NECESSARY; ALSO INSPECT REAR DOOR HINGES FOR CORROSION AND REPLACE IF NECESSARY.
|
|
|
Used 1984 Isuzu Trooper Recalls
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 49,300
Summary:
TRUCKS USED IN THE SALT-BELT STATES CAN HAVE ACCUMULATED CORROSION IN THE HINGES OF THE REAR DOORS. IF THE VEHICLES ALSO HAVE MISALIGNED DOOR LATCHES AND STRIKERS, IT IS POSSIBLE TO CLOSE THE DOORS IN A "FALSE LATCH" CONDITION.
Consequences:
IN THE "FALSE LATCH" CONDITION, THE REAR DOORS MAY GIVETHE IMPRESSION THAT THE DOOR IS PROPERLY LATCHED WHEN IT IS NOT. THIS COULD LEADTO PASSENGERS AND/OR CARGO FALLING FROM REAR DOORS WHICH CAN OPEN WITHOUT PRIORWARNING.
Remedy:
CHECK THE DOOR LATCHES AND STRIKERS FOR CORRECT ALIGNMENT AND REPAIR IF NECESSARY; ALSO INSPECT REAR DOOR HINGES FOR CORROSION AND REPLACE IF NECESSARY.
|
|
|
|
|
