Isuzu Rodeo Recalls
Vehicle manufacturers issue official Isuzu Rodeo recall notices to inform car owners of problems and/or defects that have been brought to the manufacturer's attention. An automotive recall requires the manufacturer to send an official notice to owners of the vehicles found to be defective once the NHTSA deems the problem to be wide spread and an official Isuzu Rodeo recall. View listings of Isuzu Rodeo recalls from NHTSA below with full details, vehicles affected, date reported, and more.
|
|
 |
Used 2004 Isuzu Rodeo Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 15,515
Summary:
CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.
Consequences:
A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.
Remedy:
FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.
|
|
 |
Used 2003 Isuzu Rodeo Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 15,515
Summary:
CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.
Consequences:
A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.
Remedy:
FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.
Components: SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE WARNING
Cars Affected: 55
Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, ¿CONTROLS AND DISPLAYS.¿ THE BRAKE WARNING LAMP WOULD NOT ILLUMINATE IN THE EVENT OF DECREASED BRAKE FLUID VOLUME.
Consequences:
Remedy:
THE DIODES HAVE BEEN REPLACED. ALL VEHICLES HAVE BEEN REPAIRED.
|
|
 |
Used 2002 Isuzu Rodeo Recalls
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 15,515
Summary:
CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.
Consequences:
A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.
Remedy:
FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.
|
|
 |
Used 2001 Isuzu Rodeo Recalls
Components: AIR BAGS:FRONTAL
Cars Affected: 15
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequences:
IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy:
DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Components: AIR BAGS:FRONTAL
Cars Affected: 3
Summary:
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequences:
IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy:
DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 3,052
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DURING THE MANUFACTURE OF CERTAIN FUEL RETURN HOSES, INCORRECT RUBBER MATERIAL FOR THE OUTER LAYER WAS USED.
Consequences:
THE FUEL RETURN HOSE DOES NOT MEET OZONE-RESISTANT SPECIFICATIONS, AND COULD ULTIMATELY CRACK, CAUSING FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL INSPECT THE VEHICLE TO DETERMINE IF THE VEHICLE WAS EQUIPPED WITH AN INCORRECT HOSE. IF IT IS INCORRECT, DEALERS WILL REPLACE IT.
|
|
 |
Used 2000 Isuzu Rodeo Recalls
Components: AIR BAGS:FRONTAL
Cars Affected: 15
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequences:
IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy:
DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 0
Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.
Consequences:
THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.
Remedy:
DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.
Components: AIR BAGS:FRONTAL
Cars Affected: 3
Summary:
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequences:
IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy:
DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
|
|
 |
Used 1999 Isuzu Rodeo Recalls
Components: SERVICE BRAKES, HYDRAULIC:ANTILOCK
Cars Affected: 161,927
Summary:
ON CERTAIN SPORT UTILITY VEHICLES THAT ARE EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS), THE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES IN CERTAIN TYPES OF BRAKING EVENTS.
Consequences:
EXTENDED STOPPING DISTANCE COULD RESULT, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL PROVIDE A REPLACEMENT COMPUTER ALGORITHM FOR THE ABS THAT IS BASED ON THE ALGORITHM USED IN ISUZU'S MY 2000 AND 2001 VEHICLES, WHICH HAVE NOT HAD THE PROBLEM. THIS CAMPAIGN WILL BE CONDUCTED IN PHASES, WITH THE MY 1998 2WD VEHICLES COVERED FIRST, SINCE THEY HAVE EXPERIENCED THE MOST PROBLEMS. OWNER NOTIFICATION BEGAN MARCH 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 0
Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.
Consequences:
THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.
Remedy:
DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.
Components: STRUCTURE:BODY
Cars Affected: 45,252
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequences:
IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy:
DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
Components: SUSPENSION:REAR
Cars Affected: 213,736
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequences:
THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy:
DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
|
|
 |
Used 1998 Isuzu Rodeo Recalls
Components: SERVICE BRAKES, HYDRAULIC:ANTILOCK
Cars Affected: 161,927
Summary:
ON CERTAIN SPORT UTILITY VEHICLES THAT ARE EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS), THE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES IN CERTAIN TYPES OF BRAKING EVENTS.
Consequences:
EXTENDED STOPPING DISTANCE COULD RESULT, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL PROVIDE A REPLACEMENT COMPUTER ALGORITHM FOR THE ABS THAT IS BASED ON THE ALGORITHM USED IN ISUZU'S MY 2000 AND 2001 VEHICLES, WHICH HAVE NOT HAD THE PROBLEM. THIS CAMPAIGN WILL BE CONDUCTED IN PHASES, WITH THE MY 1998 2WD VEHICLES COVERED FIRST, SINCE THEY HAVE EXPERIENCED THE MOST PROBLEMS. OWNER NOTIFICATION BEGAN MARCH 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 0
Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.
Consequences:
THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.
Remedy:
DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.
Components: SUSPENSION:REAR
Cars Affected: 213,736
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequences:
THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy:
DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Components: ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Cars Affected: 55,475
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequences:
IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Components: UNKNOWN OR OTHER
Cars Affected: 233
Summary:
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequences:
THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy:
ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
|
|
 |
Used 1997 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
|
|
|
Used 1996 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
|
|
|
Used 1995 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Components: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Cars Affected: 118,485
Summary:
AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.
Consequences:
THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.
Remedy:
DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.
|
|
|
Used 1994 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Components: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Cars Affected: 14,449
Summary:
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequences:
THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy:
DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MID-DECEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Components: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Cars Affected: 118,485
Summary:
AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.
Consequences:
THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.
Remedy:
DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.
Components: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Cars Affected: 36,075
Summary:
THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequences:
THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy:
DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 122,297
Summary:
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequences:
THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy:
DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
|
|
|
Used 1993 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 122,297
Summary:
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequences:
THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy:
DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
|
|
|
Used 1992 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
|
|
|
Used 1991 Isuzu Rodeo Recalls
Components: EXTERIOR LIGHTING
Cars Affected: 3,593
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequences:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 3,023
Summary:
THE TRANSMISSION FLUID LEVEL GAUGES (DIP STICKS) INSTALLED IN THESE VEHICLES ARE NOT TO DESIGNED SPECIFICATIONS. THE GAUGE INDICATES THAT TRANSMISSION FLUID SHOULD BE ADDED WHEN IT IS AT THE CORRECT LEVEL.
Consequences:
ADDING MORE TRANSMISSION FLUID THAN REQUIRED WILL CAUSETHE FLUID TO LEAK THROUGH THE FLUID LEVEL GAUGE TUBE ONTO THE MANIFOLD AS THEENGINE TEMPERATURE RISES. THIS CREATES A POTENTIAL FOR A FIRE.
Remedy:
REPLACE OIL LEVEL GAUGE AND NOTIFY OWNERS TO USE ONLY THE SPECIFIED AMOUNT OF AUTOMATIC TRANSMISSION FLUID.
|
|
|
|
|
