 |
Used 2008 Mitsubishi Outlander Recalls
Components: SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
Cars Affected: 39,711
Summary:
MITSUBISHI IS RECALLING 39,711 MY 2008-2009 OUTLANDER AND LACER VEHICLES. INCORRECT MATERIAL COMPOSITION OF THE BRAKE BOOSTER CHECK VALVE MAY CAUSE THE CHECK VALVE TO STICK CLOSED WHEN THE ENGINE IS SHUT OFF. WHEN THE VEHICLE IS RE-STARTED AND PUT INTO MOTION, UNDER CERTAIN DRIVING CONDITIONS (VERY SLOW VEHICLE MANEUVERS), THERE MAY BE INSUFFICIENT INITIAL BRAKING ASSIST.
Consequences:
THIS MAY TEMPORARILY INCREASE THE STOPPING DISTANCE OF THE VEHICLE AND THEREFORE INCREASE THE RISK OF A CRASH.
Remedy:
DEALERS WILL REPLACE THE BRAKE BOOSTER CHECK VALVE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
Components: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Cars Affected: 21,493
Summary:
MITSUBISHI IS RECALLING 21,493 MY 2007-2008 OUTLANDER VEHICLES EQUIPPED WITH LED TYPE STOP LAMPS AND DISTRIBUTED IN THE UNITED STATES AND PUERTO RICO. THE BRAKE LAMP SWITCH MAY MALFUNCTION AND CAUSE THE STOP LAMPS TO NOT ILLUMINATE DURING BRAKE APPLICATION.
Consequences:
THE FAILURE OF THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED WILL NOT PROVIDE WARNING TO FOLLOWING TRAFFIC AND COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL REPLACE THE STOP LAMP SWITCH. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
Components: SEATS
Cars Affected: 5,400
Summary:
MITSUBISHI IS RECALLING 5,400 MY 2007-2008 OUTLANDER PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. FOR VEHICLES WITHOUT AN ELECTRIC POWER SEAT, THE FLOOR HARNESS CONNECTOR FOR THE POWER SEAT IS PLACED DIRECTLY ON THE FLOORBOARD UNDERNEATH THE CARPETING (VEHICLES WITH POWER SEATS ALREADY HAVE THE HARNESS ELEVATED). IF A VEHICLE OCCUPANT ENTERS THE VEHICLE WITH A SUFFICIENT AMOUNT OF SNOW ON THEIR FEET CONTAINING ROAD SALT, IT IS POSSIBLE FOR THE MELTED SNOW MIXTURE TO SOAK THE CARPET AND ALLOW THE SALT-WATER SOLUTION TO COME INTO CONTACT WITH THE UNUSED POWER SEAT HARNESS CONNECTOR.
Consequences:
THE CONNECTOR TERMINAL MAY CORRODE AND ALLOW CURRENT TO FLOW, RESULTING IN THE GRADUAL HEATING AND MELTING OF THE CONNECTOR AND MAY RESULT IN A FIRE.
Remedy:
DEALERS WILL RELOCATE THE FLOOR HARNESS FROM BENEATH BOTH THE PASSENGER AND DRIVER SEATS TO ABOVE THE CARPET AND AWAY FROM THE BOTTOM OF THE FLOORBOARD TO PREVENT CONTACT WITH ANY FUTURE MELT SOLUTION. THE RECALL BEGAN ON APRIL 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
|
|
 |
Used 2007 Mitsubishi Outlander Recalls
Components: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Cars Affected: 21,493
Summary:
MITSUBISHI IS RECALLING 21,493 MY 2007-2008 OUTLANDER VEHICLES EQUIPPED WITH LED TYPE STOP LAMPS AND DISTRIBUTED IN THE UNITED STATES AND PUERTO RICO. THE BRAKE LAMP SWITCH MAY MALFUNCTION AND CAUSE THE STOP LAMPS TO NOT ILLUMINATE DURING BRAKE APPLICATION.
Consequences:
THE FAILURE OF THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED WILL NOT PROVIDE WARNING TO FOLLOWING TRAFFIC AND COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL REPLACE THE STOP LAMP SWITCH. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
Components: SEATS
Cars Affected: 5,400
Summary:
MITSUBISHI IS RECALLING 5,400 MY 2007-2008 OUTLANDER PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. FOR VEHICLES WITHOUT AN ELECTRIC POWER SEAT, THE FLOOR HARNESS CONNECTOR FOR THE POWER SEAT IS PLACED DIRECTLY ON THE FLOORBOARD UNDERNEATH THE CARPETING (VEHICLES WITH POWER SEATS ALREADY HAVE THE HARNESS ELEVATED). IF A VEHICLE OCCUPANT ENTERS THE VEHICLE WITH A SUFFICIENT AMOUNT OF SNOW ON THEIR FEET CONTAINING ROAD SALT, IT IS POSSIBLE FOR THE MELTED SNOW MIXTURE TO SOAK THE CARPET AND ALLOW THE SALT-WATER SOLUTION TO COME INTO CONTACT WITH THE UNUSED POWER SEAT HARNESS CONNECTOR.
Consequences:
THE CONNECTOR TERMINAL MAY CORRODE AND ALLOW CURRENT TO FLOW, RESULTING IN THE GRADUAL HEATING AND MELTING OF THE CONNECTOR AND MAY RESULT IN A FIRE.
Remedy:
DEALERS WILL RELOCATE THE FLOOR HARNESS FROM BENEATH BOTH THE PASSENGER AND DRIVER SEATS TO ABOVE THE CARPET AND AWAY FROM THE BOTTOM OF THE FLOORBOARD TO PREVENT CONTACT WITH ANY FUTURE MELT SOLUTION. THE RECALL BEGAN ON APRIL 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
|
|
 |
Used 2004 Mitsubishi Outlander Recalls
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 100,432
Summary:
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequences:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy:
MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Components: TRAILER HITCHES
Cars Affected: 2,175
Summary:
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
Consequences:
OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
Remedy:
OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Components: VISIBILITY:WINDSHIELD WIPER/WASHER
Cars Affected: 394
Summary:
ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP TIME INTERVAL MAY INCREASE AS MUCH AS 6.8 SECOND BETWEEN WIPER SWEEPS.
Consequences:
IF THIS OCCURS DURING SEVERE WEATHER AND DURING VEHICLE¿S HIGH-SPEED OPERATION, THE DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD LEAD TO A CRASH.
Remedy:
DEALERS WILL REPLACE THE ETACS MODULE. OWNER NOTIFICATION BEGAN NOVEMBER 14, 2003. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-800-981-0452.
|
|
 |
Used 2003 Mitsubishi Outlander Recalls
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 100,432
Summary:
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequences:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy:
MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Components: TRAILER HITCHES
Cars Affected: 2,175
Summary:
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
Consequences:
OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
Remedy:
OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Cars Affected: 134,000
Summary:
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, ¿CHILD RESTRAINT ANCHORAGE SYSTEMS.¿ THE OWNER¿S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.
Consequences:
IF THE TETHER STRAP IS IMPROPERLY INSTALLED TO THE TETHER ANCHOR, THE CHILD SAFETY SEAT MAY NOT BE SUFFICIENT RESTRAINED. IN THE EVENT OF A CRASH, THE CHILD COULD BE INJURED.
Remedy:
A LETTER OUTLINING THE PROBLEM WILL BE SENT TO OWNERS ALONG WITH A STICKER CONTAINING THE CORRECT INSTRUCTIONS AS WELL AS INSTRUCTIONS ON WHERE TO AFFIX THE STICKER IN THE OWNER¿S MANUAL. THE RECALL BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Components: ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
Cars Affected: 43,649
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, WATER COULD ENTER THE FRONT FLOORBOARD AREA FROM OPENINGS IN THE SIDE SILL OR UPPER DASH AREA. THIS WATER COULD COLLECT UNDER THE SEAT AND CAUSE ELECTRICAL CORROSION TO OCCUR IN THE HARNESS CONNECTORS THAT CONTAIN THE WIRING FOR THE SEAT BELT PRE-TENSIONER, SIDE AIR BAG IMPACT SENSOR, AND STOP LAMPS.
Consequences:
ELECTRICAL CORROSION OF THE HARNESS COULD CAUSE THE SEAT BELT PRE-TENSIONER TO MALFUNCTION, THE SIDE AIR BAG NOT TO DEPLOY AND/OR THE BRAKE LAMPS NOT TO ILLUMINATE OR TO FALSELY ILLUMINATE.
Remedy:
DEALERS WILL INSPECT THE SIDE SILLS AND DASH PANEL FOR OPENINGS THAT MAY ALLOW WATER LEAKAGE INTO THE VEHICLE CABIN. IN ADDITION TO SEALING ANY OPENINGS THAT MAY BE FOUND, THE WIRING CONNECTORS WILL BE INSPECTED FOR SIGNS OF ELECTRICAL CORROSION. THE FLOOR HARNESS WILL BE REPLACED IF IT HAS ANY SIGNS OF WATER DAMAGE OR ELECTRICAL CORROSION. OWNER NOTIFICATION BEGAN JUNE 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Components: VEHICLE SPEED CONTROL
Cars Affected: 31,000
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, DURING EXTREMELY LOW TEMPERATURE CONDITIONS, ICE CAN BUILD UP INSIDE THE ENGINE THROTTLE VALVE. THIS ICE BUILD-UP COULD CAUSE THE ACCELERATOR PEDAL TO STICK OR NOT TO RETURN TO IDLE AFTER ACCELERATING.
Consequences:
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
DEALERS WILL REPROGRAM THE ENGINE CONTROL COMPUTER TO ELIMINATE THIS CONDITION. OWNER NOTIFICATION BEGAN ON JANUARY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
|
|
|
