 |
Used 1994 Pontiac Sunbird Recalls
Components: STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
Cars Affected: 65
Summary:
THESE VEHICLES WERE BUILT WITH OVERTORQUED DRIVE AXLE SPINDLE NUTS. THIS CONDITION CAN CAUSE EXCESSIVE LOADS ON THE SPINDLE NUT AND DRIVE AXLE RESULTING IN FAILURE OF THE DRIVE AXLE OR THE SPINDLE NUT. FAILURE OF EITHER OF THESE COMPONENTS CAN RESULT IN SEPARATION OF THE STEERING KNUCKLE TIRE-WHEEL ASSEMBLY FROM THE DRIVE AXLE.
Consequences:
THIS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE ACCIDENT.
Remedy:
DEALERS WILL REPLACE THE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES. CORRECTIVE ACTION: DEALERS WILL REPLACE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES.
|
|
|
Used 1993 Pontiac Sunbird Recalls
Components: VEHICLE SPEED CONTROL
Cars Affected: 108,898
Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING VERY COLD WEATHER, WATER THATN ENTERS THE ACCELERATOR CONTROL CABLE CONDUIT FREEZES AND CAUSES THE ACCELERATOR CABLE TO DEVELOP A HIGH EFFORT OR BINDING CONDITION.
Consequences:
IF THIS OCCURS, LOSS OF NORMAL THROTTLE CONTROL CAN RESULT, OR THE THROTTLE WILL NOT RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, CAUSING POSSIBLE LOSS OF CONTROL AND AN ACCIDENT.
Remedy:
DEALERS WILL REPLACE THE ACCELERATOR CONTROL ASSEMBLY.
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 2,848
Summary:
THE BRAKE HOSES WERE MANUFACTURED INCORRECTLY, AND DO NOT COMPLY WITH FMVSS 106, "BRAKE HOSES."
Consequences:
THE IMPROPERLY MANUFACTURED BRAKE HOSES CAN CAUSEREDUCED BRAKE EFFECTIVENESS AND/OR UNEVEN BRAKING, WHICH COULD RESULT IN ANACCIDENT.
Remedy:
REPLACE THE RIGHT FRONT BRAKE HOSE ASSEMBLY ON CIERA AND CENTURY MODELS, AND BOTH REAR BRAKE HOSES ON CAVALIER AND SUNBIRD MODELS.
|
|
|
Used 1992 Pontiac Sunbird Recalls
Components: VEHICLE SPEED CONTROL
Cars Affected: 108,898
Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING VERY COLD WEATHER, WATER THATN ENTERS THE ACCELERATOR CONTROL CABLE CONDUIT FREEZES AND CAUSES THE ACCELERATOR CABLE TO DEVELOP A HIGH EFFORT OR BINDING CONDITION.
Consequences:
IF THIS OCCURS, LOSS OF NORMAL THROTTLE CONTROL CAN RESULT, OR THE THROTTLE WILL NOT RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, CAUSING POSSIBLE LOSS OF CONTROL AND AN ACCIDENT.
Remedy:
DEALERS WILL REPLACE THE ACCELERATOR CONTROL ASSEMBLY.
Components: VEHICLE SPEED CONTROL
Cars Affected: 22,452
Summary:
THE ACCELERATOR CABLE MAY HAVE BEEN KINKED DURING VEHICLE ASSEMBLY. THE KINK IN THE CABLE CAN CAUSE EITHER A HIGH EFFORT ACCELERATOR CABLE, STICKING ACCELERATOR CABLE, OR A BROKEN ACCELERATOR CABLE.
Consequences:
IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS IT CANRESULT IN LOSS OF THROTTLE CONTROL. IF LOSS OF THROTTLE CONTROL OCCURS WHILE THEVEHICLE IS IN MOTION, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy:
REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.
Components: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Cars Affected: 3,212
Summary:
THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.
Consequences:
IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.
Remedy:
INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.
|
|
|
Used 1991 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: SEAT BELTS
Cars Affected: 347,866
Summary:
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequences:
THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy:
INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Cars Affected: 41,718
Summary:
FRONT DOOR INTERLOCK STRIKER MAY FAIL, CAUSING DOOR FRAME COLLAPSE AND INSUFFICIENT STRENGTH FOR THE SHOULDER BELT ANCHORAGE.
Consequences:
THE DOOR FRAME WOULD COLLAPSE. VEHICLE DOES NOT COMPLYWITH FMVSS 210.
Remedy:
REPLACE THE PASSIVE RESTRAINT INTERLOCK STRIKER STUDS ON FRONT DOORS.
|
|
|
Used 1990 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
|
|
|
Used 1989 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Cars Affected: 13,095
Summary:
A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.
Consequences:
IN PRESENCE OF AN IGNITION SOURCE, THIS CONDITION COULDRESULT IN A FIRE.
Remedy:
REPLACE FUEL TANK.
|
|
|
Used 1988 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: VISIBILITY:WINDSHIELD
Cars Affected: 33
Summary:
THERE MAY BE POOR BOND ADHESION BETWEEN WINDSHIELD GLASS AND MOUNTING.
Consequences:
WINDSHIELD COULD SEPARATE DURING A 30 MPH FRONTAL BARRIERTEST REQUIRED BY FMVSS 212. SUCH SEPARATION DURING AN ACCIDENT COULD RESULT INAN UNBELTED OCCUPANT BEING EJECTED AND INJURIED.
Remedy:
REINSTALL WINDSHIELD ASSURING PROPER ADHESION.
Components: ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
Cars Affected: 14,840
Summary:
REAR LAMP WIRING HARNESS MAY CONTAIN OPEN OR INTERMITTENT CIRCUITS AFFECTING BACK UP LAMP OR LICENSE PLATE LAMP OPERATION.
Consequences:
LAMPS WOULD FLASH OR BE INOPERATIVE; CARS WOULD NOTCOMPLY WITH FMVSS 108.
Remedy:
INSTALL NEW WIRING HARNESS.
|
|
|
Used 1987 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FIL...
Cars Affected: 131,476
Summary:
THE FUEL FEED AND/OR RETURN HOSE/PIPE ASSEMBLIES COULD CRACK OR SEPARATE, ALLOWING FUEL TO LEAK INTO THE UNDERHOOD AREA.
Consequences:
THIS COULD RESULT IN AN UNDERHOOD FIRE, WITHOUT PRIORWARNING, AND CAUSE INJURY TO OCCUPANTS.
Remedy:
REPLACE BOTH FUEL FEED AND RETURN HOSE/PIPE ASSEMBLIES.
|
|
|
Used 1986 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Components: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Cars Affected: 93,317
Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Consequences:
Remedy:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
|
|
|
Used 1985 Pontiac Sunbird Recalls
Components: FUEL SYSTEM, GASOLINE
Cars Affected: 88,303
Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequences:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
|
|
|
Used 1980 Pontiac Sunbird Recalls
Components: SEAT BELTS:FRONT:RETRACTOR
Cars Affected: 55,238
Summary:
ON CERTAIN VEHICLES, THE SEAT BELT RETRACTORS IN THE REAR SEATING POSITIONS CONTAIN FIRST LOCK POSITIONS WHICH WILL NOT LOCK WHEN USED BY SMALLER PASSENGERS. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".
Consequences:
Remedy:
ALL OWNERS WILL BE SENT A PRE-PAID POSTAGE CARD THAT IS TO BE FILLED OUT AND SENT BACK. THE CARD WILL INDICATE WHETHER THE SEAT BELTS ARE FUNCTIONING PROPERLY. IF DEALER INSPECTS SEAT BELTS, THE SEAT BELT RETRACTORS WILL BE REPLACED, IF NECESSARY, WITHOUT CHARGE.
|
|
|
Used 1979 Pontiac Sunbird Recalls
Components: EQUIPMENT
Cars Affected: 121,680
Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequences:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 42,977
Summary:
THE CARBURETOR FUEL FEED HOSE MAY NOT HAVE BEEN PROPERLY POSITIONED DURING ASSEMBLY. AS A RESULT THE HOSE COULD COME IN CONTACT WITH OR BE TOO CLOSE TO THE ENGINE EMISSION EXHAUST SYSTEM GAS RECIRCULATION VALVE. THIS CAN CAUSE THE HOSE TO RUPTURE.
Consequences:
Remedy:
THE DEALER WILL INSPECT THE FUEL FEED HOSE AND REPOSITION IT, IF NECESSARY. ALSO, ANY DAMAGED HOSE WILL BE REPLACED.
Components: ELECTRICAL SYSTEM:WIRING
Cars Affected: 4,208
Summary:
THE ENGINE OIL PRESSURE SWITCH MAY CAUSE A RANDOM INTERNAL ELECTRICAL SHORT WHICH COULD RESULT IN THE ENGINE STARTING BY ITSELF WHEN THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION.
Consequences:
Remedy:
DEALER WILL REPLACE THE OIL PRESSURE SWITCHES ON ALL SUSPECT VEHICLES AT NO COST TO OWNER.
|
|
|
Used 1978 Pontiac Sunbird Recalls
Components: EQUIPMENT
Cars Affected: 121,680
Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequences:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 172,000
Summary:
OPERATION OF THE VEHICLE IN A MANNER WHICH PRODUCES HARD BOTTOMING OUT OF THE FRONT SUSPENSION MAY CAUSE DEFORMATION OF THE LEFT ENGINE MOUNT SUPPORT STRUCTURE AND ALLOW THE ENGINE MOUNT BRACKET TO CONTACT THE STEERING PITMAN ARM OR STEERING LINKAGE.
Consequences:
Remedy:
AN ENGINE MOUNT SUPPORT BRACKET REINFORCEMENT KIT WILL BE INSTALLED ON THE LEFT FRONT ENGINE MOUNT SUPPORT STRUCTURE WITHOUT CHARGE TO OWNER.
Components: STEERING:WHEEL AND HANDLE BAR
Cars Affected: 22,268
Summary:
THE INTERMEDIATE SHAFT COUPLING ON THE INVOLVED VEHICLES MAY HAVE BEEN MACHINED OVERSIZED IN THE SERRATION AREA WHERE IT ATTACHES TO THE STEERING COLUMN. THIS WOULD PREVENT THE COUPLING FROM PROPERLY TIGHTENING ON THE SHAFT WHEN THE CLAMP AND PINCH BOLT WERE INSTALLED.
Consequences:
Remedy:
DEALER WILL REPLACE THE SHAFT COUPLING, IF NECESSARY, WITHOUT CHARGE TO OWNER.
|
|
|
Used 1977 Pontiac Sunbird Recalls
Components: EQUIPMENT
Cars Affected: 121,680
Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequences:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 172,000
Summary:
OPERATION OF THE VEHICLE IN A MANNER WHICH PRODUCES HARD BOTTOMING OUT OF THE FRONT SUSPENSION MAY CAUSE DEFORMATION OF THE LEFT ENGINE MOUNT SUPPORT STRUCTURE AND ALLOW THE ENGINE MOUNT BRACKET TO CONTACT THE STEERING PITMAN ARM OR STEERING LINKAGE.
Consequences:
Remedy:
AN ENGINE MOUNT SUPPORT BRACKET REINFORCEMENT KIT WILL BE INSTALLED ON THE LEFT FRONT ENGINE MOUNT SUPPORT STRUCTURE WITHOUT CHARGE TO OWNER.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 314
Summary:
ON THE INVOLVED VEHICLES, THE INCORRECT FUEL HOSE PIPE WAS INSTALLED. CONSEQUENTLY, THE NEEDED SPECIAL REINFORCEMENT, USED TO HELP PREVENT RUPTURE OF THE HOSE AND SPILLAGE OF FUEL RESULTING FROM AN IMPACT FROM THE SIDE, WAS OMITTED. THIS WOULD CONSTITUTE A NON-COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 310, "FUEL SYSTEM INTEGRITY".
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, INSTALL THE CORRECT FUEL HOSE WITHOUT CHARGE TO OWNER.
|
|
|
Used 1976 Pontiac Sunbird Recalls
Components: EQUIPMENT
Cars Affected: 121,680
Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequences:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 34,208
Summary:
Consequences:
Remedy:
Components: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Cars Affected: 20
Summary:
Consequences:
Remedy:
|
|
|
