 |
Used 1991 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 358,000
Summary:
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
Consequences:
FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.
Remedy:
REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.
|
|
|
Used 1990 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIP...
Cars Affected: 358,000
Summary:
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
Consequences:
FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.
Remedy:
REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.
|
|
|
Used 1989 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: VEHICLE SPEED CONTROL
Cars Affected: 300
Summary:
WHEN USING THE CRUISE CONTROL THE ACCELERATOR CABLE TENSION MAY ALLOW THE CABLE TO SAG AND BECOME ENTANGLED WITH THE WATER PIPE BRACKET IMPEDING ITS RETURN TO IDLE POSITION.
Consequences:
FAILURE TO RETURN TO IDLE POSITION COULD LEAD TO ANACCIDENT.
Remedy:
THE PRESENT ACCELERATOR CABLE BRACKET WILL BE REPLACED.
|
|
|
Used 1988 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: VEHICLE SPEED CONTROL
Cars Affected: 300
Summary:
WHEN USING THE CRUISE CONTROL THE ACCELERATOR CABLE TENSION MAY ALLOW THE CABLE TO SAG AND BECOME ENTANGLED WITH THE WATER PIPE BRACKET IMPEDING ITS RETURN TO IDLE POSITION.
Consequences:
FAILURE TO RETURN TO IDLE POSITION COULD LEAD TO ANACCIDENT.
Remedy:
THE PRESENT ACCELERATOR CABLE BRACKET WILL BE REPLACED.
Components: TIRES
Cars Affected: 130
Summary:
DUE TO IMPROPER MOUNTING PROCESS, SEMPERIT TIRES 20570R14 MOUNTED ON ALLOY WHEEL SIZE 6J X 14 COULD EXPERIENCE TINY CRACKS IN THE BEAD AREA.
Consequences:
TIRES COULD LOSE AIR, CREATING POTENTIAL FOR LOSS OFVEHICLE CONTROL.
Remedy:
REPLACE TIRES AS NECESSARY.
Components: EQUIPMENT:MECHANICAL:JACKS
Cars Affected: 600
Summary:
IMPROPER JACK FURNISHED WITH VEHICLES.
Consequences:
THE JACK MAY NOT REACH FAR ENOUGH INTO THE JACKETSPROVIDED ON BOTH SIDED OF THE VEHICLE. IF THE IMPROPER JACK IS USED, IT COULDSLIP AND POSSIBLY INJURE A PERSON STANDING TOO CLOSE TO THE VEHICLE.
Remedy:
REPLACE JACK WITH THE PROPER TYPE FOR VEHICLE.
|
|
|
Used 1987 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: VEHICLE SPEED CONTROL
Cars Affected: 300
Summary:
WHEN USING THE CRUISE CONTROL THE ACCELERATOR CABLE TENSION MAY ALLOW THE CABLE TO SAG AND BECOME ENTANGLED WITH THE WATER PIPE BRACKET IMPEDING ITS RETURN TO IDLE POSITION.
Consequences:
FAILURE TO RETURN TO IDLE POSITION COULD LEAD TO ANACCIDENT.
Remedy:
THE PRESENT ACCELERATOR CABLE BRACKET WILL BE REPLACED.
Components: TIRES
Cars Affected: 130
Summary:
DUE TO IMPROPER MOUNTING PROCESS, SEMPERIT TIRES 20570R14 MOUNTED ON ALLOY WHEEL SIZE 6J X 14 COULD EXPERIENCE TINY CRACKS IN THE BEAD AREA.
Consequences:
TIRES COULD LOSE AIR, CREATING POTENTIAL FOR LOSS OFVEHICLE CONTROL.
Remedy:
REPLACE TIRES AS NECESSARY.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 12,000
Summary:
IN LINE FUEL FILTER LOCATED BETWEEN THE FUEL TANK AND FUEL PUMP COULD SEEP FUEL AT THE SEAM OF THE PLASTIC CASING.
Consequences:
SHOULD SEEPAGE OCCUR, LEAKING FUEL CAN CAUSE A RISK OFFIRE IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy:
THE IN LINE FUEL FILTER WILL BE REPLACED WITH A STRAIGHT FUEL HOSE.
Components: POWER TRAIN:AUTOMATIC TRANSMISSION
Cars Affected: 1,600
Summary:
PIN IN SHIFT LOCKING PAWL MAY NOT BE PROPERLY WELDED TO THE PAWL.
Consequences:
IF PIN SEPARATES FROM PAWL, DRIVER WOULD BE ABLE TO MOVETHE SHIFT LEVER DURING DRIVING INTO ANY POSITION WITHOUT PRESSING SAFETYRELEASE BUTTON.
Remedy:
REPLACE SHIFT LOCKING PAWL.
Components: SEATS:MID/REAR ASSEMBLY
Cars Affected: 2,397
Summary:
SEAT BRACKETS WHICH ANCHOR REARWARD PASSENGER SEATS MAY NOT ENGAGE PROPERLY.
Consequences:
SEAT COULD BREAK LOOSE DURING ACCELERATION AND CAUSEINJURY TO THE SEAT OCCUPANT.
Remedy:
ASSURE THAT SEAT BRACKETS ARE PROPERLY ENGAGED.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Cars Affected: 15,500
Summary:
USAGE OF FUEL WITH REID PRESSURE UP TO 14 PSI COULD, UNDER HIGH ENGINE LOAD AND HIGH AMBIENT TEMPERATURES, LEAD TO STALLING.
Consequences:
FUEL FLOW COULD BECOME RESTRICTED AND CAUSE THE ENGINETO STALL.
Remedy:
INSTALL A NEW FUEL TANK, CONTAINING A REDESIGNED FUEL FILTER, AS WELL AS MODIFIED CONTROL UNITS.
|
|
|
Used 1986 Volkswagen Vanagon Recalls
Components: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
Cars Affected: 29,500
Summary:
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequences:
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
Components: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Cars Affected: 12,000
Summary:
IN LINE FUEL FILTER LOCATED BETWEEN THE FUEL TANK AND FUEL PUMP COULD SEEP FUEL AT THE SEAM OF THE PLASTIC CASING.
Consequences:
SHOULD SEEPAGE OCCUR, LEAKING FUEL CAN CAUSE A RISK OFFIRE IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy:
THE IN LINE FUEL FILTER WILL BE REPLACED WITH A STRAIGHT FUEL HOSE.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Cars Affected: 15,500
Summary:
USAGE OF FUEL WITH REID PRESSURE UP TO 14 PSI COULD, UNDER HIGH ENGINE LOAD AND HIGH AMBIENT TEMPERATURES, LEAD TO STALLING.
Consequences:
FUEL FLOW COULD BECOME RESTRICTED AND CAUSE THE ENGINETO STALL.
Remedy:
INSTALL A NEW FUEL TANK, CONTAINING A REDESIGNED FUEL FILTER, AS WELL AS MODIFIED CONTROL UNITS.
Components: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FIL...
Cars Affected: 339
Summary:
FUEL TANK FILLER NECK PIPE MAY NOT SEAT PROPERLY IN THE FUEL TANK OPENING. ALSO, THE SENDING UNIT COVER MAY BE DEFORMED.
Consequences:
FUEL COULD ESCAPE, CREATING THE POTENTIAL FOR A FIRE.
Remedy:
INSTALL A REDESIGNED FILLER NECK PIPE AND REPLACE THE SENDING UNIT GASKET.
|
|
|
Used 1985 Volkswagen Vanagon Recalls
Components: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Cars Affected: 18,328
Summary:
THE LATCH OF THE PASSENGER SIDE SLIDING DOOR MAY BECOME DAMAGED IF EXCESSIVE FORCE IS USED TO CLOSE THE DOOR. THE DAMAGED DOOR LOCK MECHANISM WILL NOT PROPERLY ENGAGE AND THE DOOR COULD OPEN IF VEHICLE IS DRIVEN OVER BUMPY ROADS. CONSEQUENCE OF DEFECT: IF THIS OCCURS THERE IS A POSSIBILITY THAT A PASSENGER COULD FALL OUT CAUSING INJURY OR DEATH.
Consequences:
Remedy:
MODIFY THE SLIDING DOOR LOCK ASSEMBLY SO DOOR WILL PROPERLY ENGAGE.
|
|
|
Used 1982 Volkswagen Vanagon Recalls
Components: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Cars Affected: 16,000
Summary:
SPRING, WHICH HOLDS THE LATCH ON THE FRONT DOOR LOCKS, MAY BREAK AND DOOR MAY OPEN UNEXPECTEDLY.
Consequences:
Remedy:
SPRINGS WILL BE REPLACED ON ALL AFFECTED LOCKS WITHOUT CHARGE.
|
|
|
Used 1981 Volkswagen Vanagon Recalls
Components: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Cars Affected: 16,000
Summary:
SPRING, WHICH HOLDS THE LATCH ON THE FRONT DOOR LOCKS, MAY BREAK AND DOOR MAY OPEN UNEXPECTEDLY.
Consequences:
Remedy:
SPRINGS WILL BE REPLACED ON ALL AFFECTED LOCKS WITHOUT CHARGE.
Components: EQUIPMENT:MECHANICAL:SLIDE-IN CAMPER
Cars Affected: 92
Summary:
DURING VEHICLE OPERATION, THE POP TOP COULD LOOSEN FROM ITS ANCHOR DUE TO WIND PRESSURE. IT COULD OPEN AND SEPARATE ENTIRELY FROM THE VEHICLE.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, MODIFY ANCHORAGES TO MAKE SURE POP TOP WILL BE SECURED UNDER NORMAL OPERATING CONDITIONS.
|
|
|
Used 1980 Volkswagen Vanagon Recalls
Components: EQUIPMENT:MECHANICAL:SLIDE-IN CAMPER
Cars Affected: 92
Summary:
DURING VEHICLE OPERATION, THE POP TOP COULD LOOSEN FROM ITS ANCHOR DUE TO WIND PRESSURE. IT COULD OPEN AND SEPARATE ENTIRELY FROM THE VEHICLE.
Consequences:
Remedy:
DEALER WILL INSPECT AND, IF NECESSARY, MODIFY ANCHORAGES TO MAKE SURE POP TOP WILL BE SECURED UNDER NORMAL OPERATING CONDITIONS.
Components: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
Cars Affected: 2,287
Summary:
THE AUXILIARY HEATER"S EXHAUST PIPE IS MOUNTED IN A DOWNWARD POSITION TOWARD THE GROUND.
Consequences:
Remedy:
DEALER WILL REMOVE THE EXISTING PIPE AND INSTALL A MODIFIED PIPE WITH A SHIELD OVER THE END, WITHOUT CHARGE TO OWNER.
Components: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Cars Affected: 2,572
Summary:
THE BOLTS WHICH ATTACH EACH LEFT AND RIGHT SIDE FRONT BALL JOINT TO THE UPPER WISHBONE, MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED DURING ASSEMBLY. THIS COULD CAUSE THE BALL JOINT TO SEPARATE FROM THE WISHBONE.
Consequences:
Remedy:
THE DEALER WILL TIGHTEN THE BALL JOINT BOLTS TO THE CORRECT SPECIFICATIONS AT NO COST TO OWNER.
|
|
|
