Volvo S80 Recalls
Vehicle manufacturers issue official Volvo S80 recall notices to inform car owners of problems and/or defects that have been brought to the manufacturer's attention. An automotive recall requires the manufacturer to send an official notice to owners of the vehicles found to be defective once the NHTSA deems the problem to be wide spread and an official Volvo S80 recall. View listings of Volvo S80 recalls from NHTSA below with full details, vehicles affected, date reported, and more.
|
|
 |
Used 2008 Volvo S80 Recalls
Components: ELECTRICAL SYSTEM: SOFTWARE
Cars Affected: 11,993
Summary:
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Consequences:
IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy:
DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Cars Affected: 17,614
Summary:
VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE IN ENGINE COOLANT TEMPERATURE.
Consequences:
THIS SITUATION MAY RESULT IN LOSS OF COOLING SYSTEM FUNCTION AND ENGINE FAILURE. THE DRIVER MAY NOT HAVE SUFFICIENT TIME TO REACT TO THE WARNING LIGHT(S) OR THE TEXT MESSAGE IN THE INSTRUMENT PANEL, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL REPLACE THE FAN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
Components: ELECTRICAL SYSTEM: SOFTWARE
Cars Affected: 12,303
Summary:
VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY ACTIVATE WHEN NOT SWITCHED ON.
Consequences:
OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.COM.
Components: ENGINE AND ENGINE COOLING:ENGINE
Cars Affected: 102
Summary:
VOLVO IS RECALLING 102 MY 2008 XC90 AND S80 VEHICLES EQUIPPED WITH V8 ENGINES. THESE VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT BOLTS TO THE ENGINE MOUNT.
Consequences:
THE ALUMINUM BRACKET FOR THE ENGINE MOUNT COULD BREAK DUE TO LACK OF ADEQUATE CLAMPING FORCE. THIS COULD CAUSE THE ENGINE TO COME IN CONTACT WITH THE SUB-FRAME, ULTIMATELY RESULTING IN A REDUCED ENGINE TORQUE OR STALLING OF THE ENGINE WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT THE ENGINE MOUNT BOLTS FOR SPECIFIC MARKINGS. IF ANY OF THE BOLTS CONTAIN THE INCORRECT MARKINGS, THE BRACKET AND BOLTS WILL BE REPLACED. ALL OWNERS HAVE BEEN CONTACTED AND ARRANGEMENTS HAVE BEEN MADE TO REPAIR THESE VEHICLES.
|
|
 |
Used 2007 Volvo S80 Recalls
Components: ELECTRICAL SYSTEM: SOFTWARE
Cars Affected: 12,303
Summary:
VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY ACTIVATE WHEN NOT SWITCHED ON.
Consequences:
OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.COM.
|
|
 |
Used 2006 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 19,700
Summary:
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, ¿TIRE SELECTION AND RIMS.¿ THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Consequences:
A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
|
|
 |
Used 2005 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 19,700
Summary:
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, ¿TIRE SELECTION AND RIMS.¿ THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Consequences:
A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Components: ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID
Cars Affected: 10,259
Summary:
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequences:
SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
|
|
 |
Used 2004 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: STEERING:LINKAGES
Cars Affected: 29,986
Summary:
ON CERTAIN PASSENGER VEHICLES, THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND, AS A RESULT, THE STUD AND NUT THAT SECURE THE ARM TO THE SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN DRIVING CONDITIONS, THE STEERING MAY BECOME LESS RESPONSIVE AND THE DRIVER MAY EXPERIENCE STEERING WHEEL PLAY.
Consequences:
THIS DRIVING CONDITION COULD EVENTUALLY LEAD TO SEPARATION BETWEEN THE FRONT CONTROL ARM AND THE SPINDLE, WHICH COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL INSTALL A NEW TYPE OF NUT. OWNER NOTIFICATION BEGAN ON FEBRUARY 16, 2004. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
|
|
 |
Used 2003 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: EQUIPMENT:OTHER:LABELS
Cars Affected: 220,407
Summary:
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER¿S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequences:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy:
OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER¿S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
|
|
 |
Used 2002 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
|
|
 |
Used 2001 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: VEHICLE SPEED CONTROL
Cars Affected: 170,099
Summary:
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequences:
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy:
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Cars Affected: 149,799
Summary:
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequences:
A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy:
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
Components: SEAT BELTS:FRONT:ANCHORAGE
Cars Affected: 3,276
Summary:
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequences:
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy:
DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
|
|
 |
Used 2000 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: VEHICLE SPEED CONTROL
Cars Affected: 170,099
Summary:
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequences:
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy:
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Cars Affected: 149,799
Summary:
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequences:
A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy:
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
Components: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Cars Affected: 49,488
Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Consequences:
THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Remedy:
DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
|
|
 |
Used 1999 Volvo S80 Recalls
Components: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS...
Cars Affected: 13,128
Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequences:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Components: VEHICLE SPEED CONTROL
Cars Affected: 170,099
Summary:
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequences:
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy:
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Cars Affected: 149,799
Summary:
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequences:
A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy:
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
Components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Cars Affected: 25,876
Summary:
ON SOME PASSENGER VEHICLES, CERTAIN ELECTRIC COOLING FANS COULD BE INADEQUATE IN A HOT CLIMATE. UNDER CERTAIN CIRCUMSTANCES, EXCESSIVE HEAT COULD BE GENERATED.
Consequences:
SHOULD THIS OCCUR, THE ENGINE COOLING FAN COMPONENTS COULD OVERHEAT AND CAUSE THE MELTING OF ELECTRICAL CONNECTIONS AND ADJACENT COMPONENTS, INCREASING THE LIKELIHOOD OF A FIRE.
Remedy:
DEALERS WILL REPLACE THE ENGINE COOLING FAN. OWNER NOTIFICATION BEGAN APRIL 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Components: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Cars Affected: 49,488
Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Consequences:
THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Remedy:
DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
|
|
|
|
